SANDPIPER U1F - Manual (Page 11)

u1fmdl1sm-rev0614 Model U1F UL79 Listed Metallic Design Level 1 Page 9
RECYCLING
Many components of SANDPIPER ®
Metallic AODD pumps are made of
recyclable materials (see chart on
page 10 for material specifications).
We encourage pump users to recycle
worn out parts and pumps whenever
possible, after any hazardous pumped
fluids are thoroughly flushed.
This pump is pressurized
internally with air pressure
during operation. Always
make certain that all bolting
is in good condition and
that all of the correct
bolting is reinstalled during assembly.
WARNING
Before pump operation,
i n s p e c t a l l g a s k e t e d
fasteners for looseness
caused by gasket creep. Re-
torque loose fasteners to
prevent leakage. Follow recommended torques
stated in this manual.
CAUTION
When used for toxic or
aggressive fluids, the pump
should always be flushed
clean prior to disassembly.
WARNING
B e f o r e m a i n t e n a n c e
or repair, shut off the
compressed air line,
bleed the pressure, and
disconnect the air line from
the pump. The discharge
line may be pressurized and must be bled of
its pressure.
WARNING
Take action to prevent static
sparking. Fire or explosion
can result, especially
when handling flammable
liquids. The pump, piping,
valves, containers or
other miscellaneous equipment must be
g r o u n d e d . ( S e e p a g e 2 2 )
WARNING
IMPORTANT
Read these safety warnings
and instructions in this
manual completely, before
installation and start-up
of the pump. It is the
responsibility of the purchaser to retain this
manual for reference. Failure to comply with
the recommendations stated in this manual will
damage the pump, and void factory warranty.
WARNING
Airborne particles and loud
noise hazards.
Wear ear and eye protection.
B e f o r e d o i n g a n y
maintenance on the pump,
be certain all pressure is
completely vented from the
pump, suction, discharge,
piping, and all other
openings and connections. Be certain the air
supply is locked out or made non-operational,
so that it cannot be started while work is being
done on the pump. Be certain that approved
eye protection and protective clothing are worn
all times in the vicinity of the pump. Failure to
follow these recommendations may result in
serious injury or death.
WARNING
WARNING
In the event of diaphragm
rupture, pumped material
may enter the air end of the
pump, and be discharged
into the atmosphere. If
pumping a product which is hazardous or toxic,
the air exhaust must be piped to an appropriate
area for safe disposition.
IMPORTANT SAFETY
INFORMATION
Underwriters Laboratories,
Inc., an Internationally
recognized independent
organization for testing
products to ensure public
safety.
Do not smoke near the
pump or use the pump
near an open flame. Fire or
explosion could result.
WARNING
WARNING
Do not use this pump with potable water
or fluids for human consumption.
CAUTION
Pump not designed,
tested or certified to be
powered by compressed
natural gas. Powering
the pump with natural
gas will void the warranty.
WARNING
Use safe practices
when lifting
kg