Philips CDR796 - Manual

For servicing CDR79x the set has to be divided into two parts:
1. Except for the CD-R/W module all workshops can repair the set on component level.
The Switched Mode Power Supply unit will be exchanged completely in case of a failure.
2.The CD-R/W module can only be repaired on component level with the help of ComPair.
With this tool diagnosing of the set can be done in an interactive way. In this tool also the adjustment procedure has
been implemented. The adjustment is absolutely necessary in case the CDR-Main Board and/or CD drive (CDR Loader)
is disconnected from the matched production combination.
Only designated workshops can perform these repairs!
Please send the complete set to the designated workshop.
Available circuit descriptions: The Basics of Compact Disc Recordable/Rewritable 4822 725 25242
2nd line Service Manual CDR Mozart Module 3122 785 60030
chapter
Technical Specification and Measurement setup................1-1, 1-2
Location of printed circuit boards ............................................1-3
Warnings & Safety ..................................................................2-1
Brief Operating Instructions ...............................................3-1 to 3-3
Dismantling Instructions.....................................................4-1 to 4-8
Service hints ......................................................................5-1 to 5-5
Service Test Program ........................................................5-7 to 5-9
BLOCK DIAGRAMS ..........................................................6-1 to 6-4
WIRING DIAGRAM.................................................................6-5
POWER BOARD (for orientation only) ...................................7-1
DISPLAY BOARD..............................................................7-2 to 7-4
KEY BOARD ...........................................................................7-5
LIGHTGUIDE BOARD ............................................................7-5
INTERFACE BOARD........................................................7-6 to 7-7
chapter
HEADPHONE BOARD ...........................................................7-8
CD LOADER .....................................................................8-1 to 8-6
EXPLODED VIEWS
apparatus ..........................................................................10-1
CD loader...........................................................................8-6
MECHANICAL PARTSLIST...................................................10-2
ELECTRICAL PARTSLIST...................................................10-3 ff
version 1.0
CDR795
/00/17
Published by MS 0217 Service Audio Printed in The Netherlands Subject to modification © 3103 785 25180
Compact Disc Recorder
CLASS 1
LASER PRODUCT
© Copyright 2002 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
CDR796
/00S
TABLE OF CONTENTS
SERVICING