Metro 9 Series Controlled Humidity Heated Holding & Proofing Cabinets - Manual (Page 15)

13
SERVICE and REPLACEMENT PARTS
C5 9 SERIES REPLACEMENT PARTS — ELECTRICAL
Confi rm the cabinet electrical rating before ordering components.
Warning: Only factory approved service agents should attempt to service, repair or replace electrical components,
wiring or power cord.
To access the controller area, remove the (7) screws holding the cabinet top in place. Lift the rear portion of the
cabinet top and slide it away from under the front control bezel, removing it from the cabinet. After servicing, replace
the cabinet top and the (7) screws holding it in place.
120V 1440W OR 2000W
ITEM # Replacement Part No. Description
1 RPC5-9CONTR 120V (°F) CONTROLLER,
SENSORS & WIRING
2 RPC13-375 MASTER SWITCH
3 RPC5-KNOB CONTROLLER KNOB
4 RPC11-191 INTAKE COLLAR
5 RPC13-685 BLOWER, 120V
6 RPC13-093 ELEMENT, 120V 1950W
6A RPC13-114 ELEMENT, 120V 1360W
7 RPC13-198 THERMAL CUT OUT
8 RPC13-359 POWER CORD, 20A RT ANGLE
PLUG
RPC13-099 POWER CORD, 20A STR PLUG
RPC5-RTWSTPLG POWER CORD, 20A TWIST LK
PLUG
RPC13-217 CORD, TWIST LOCK PLUG, 20A
8A RPC13-348 POWER CORD, 15A RT ANGLE
PLUG
RPC13-289 POWER CORD, 15A STR PLUG
RPC13-337 POWER CORD, 15A TWIST LK
PLUG
9 RPC5-RTWSTPLG POWER CORD, 20A CORD
9A RPC13-083 STRAIN RELIEF, 15A CORD
10 RPC13-096 TERMINAL BLOCK
11 RPC07-055 SENSOR CABLE GROMMET
12 RPC5-SCLP SENSOR CLAMP & SCREW
13 RPC5-WSNSR WATER SENSOR & FLGD BUSHING
14 RPC06-885 FLGD BUSHING,WATER SENSOR
15 RPC15-030 BULKHEAD FITTING
16 RPC13-200 WATER RESERVOIR ELEMENT,
120V 1950W
16A RPC13-240 WATER RESERVOIR ELEMENT,
120V 1360W
37 RPC59-FAN FAN, 120V
38 RPC59-HMDSNR HUMIDITY SENSOR
220-240V 1681W OR 2000W
ITEM # Replacement Part No. Description
1 RPC5X-9CONTR 220-240V (°C) CONTROLLER,
SENSORS & WIRING
2 RPC13-375 MASTER SWITCH
3 RPC5-KNOB CONTROLLER KNOB
4 RPC11-191 INTAKE COLLAR
5 RPHX20-2103 BLOWER, 220/240V
6 RPC13-117 ELEMENT, 240V 1950W
7 RPC13-198 THERMAL CUT OUT
8 RPC13-247 POWER CORD, 250V 15A
9 RPC13-083 STRAIN RELIEF, 15A CORD
10 RPC13-096 TERMINAL BLOCK
11 RPC07-055 SENSOR CABLE GROMMET
12 RPC5-SCLP SENSOR CLAMP & SCREW
13 RPC5-WSNSR WATER SENSOR & FLGD
BUSHING
14 RPC06-885 FLGD BUSHING,WATER SENSOR
15 RPC15-030 BULKHEAD FITTING
16 RPC13-241 WATER RESERVOIR ELEMENT,
240V 1950W
37 RPC5-EXPTFAN FAN, 220-240V
38 RPC59-HMDSNR HUMIDITY SENSOR
AIR DUCT CONTROL PANEL
L01-419 Rev. F L&M.indd 13 1/16/12 2:36 PM