Generac Power Systems 00916-1 - Manual (Page 2)

Generac NP-50G Recreational Vehicle Generator
THE MANUFACTURER SUGGESTS THAT THESE “RULES” FOR SAFE OPERATION BE COPIED AND POSTED
IN POTENTIAL HAZARD AREAS OF THE RECREATIONAL VEHICLE. SAFETY SHOULD BE STRESSED TO ALL
OPERATORS AND POTENTIAL OPERATORS OF THIS EQUIPMENT.
WARNING:
The engine exhaust from this product
contains chemicals known to the State
of Caiifomia to cause cancer, birth
defects, or other reproductive harm.
Study these SAFETY RULES carefully before installing, operating or ser­
vicing this equipment. Become famiiiar with the Owner’s Manual and with
the generator. The generator can operate safely, effidentty and reliably only
if it is properly installed, operated and maintained. Many accidents are
caused by failing to follow simple and fundamental rules or precautions.
Generac cannot possibly antidpate every possible drcumstance that might
involve a hazard. The warnings in this Manual and on tags and decals affixed
to the unit are therefore, not allH’ndi^ive. If you use a procedure, work method
or operating technique Generac does not specifically recommend, you
must satisfy yourself that It is safe for you and others. You must also make
sure the procedure, work method or operating technique that you choose
does not render the generator to be unsafe.
• For fire safety, the generator must be installed and maintained properly.
Installation must always comply with applicable codes, standards, laws
and regulations. Adhere strictly to local, state and national electrical and
building codes. Comply with regulations the Occupational Safety and
Health Administration (OSHA) established. Also, the generator and
related components must be installed completely in conformance with
the manufacturer's instructions and recommendations. Following proper
installation, do nothing that might alter a safe installation and render the
unit in non-compliance with such codes, standards, laws and regulations.
A The Recreational Vehicle Generator produces extremely high and
dangerous electrical voltages and can cause dangerous, and possi­
bly fatal, electrical shock. Avoid contact with bare wires, terminals, etc.
while the unit is running. If you must work around an operating gen­
erator, stand on an insulated, dry surface to reduce slwck hazard.
Never work on this equipment or handle any electrical device while
standing in water, while barefoot, or while hands or feet are wet Dan­
gerous electrical shock will result
• Have the generator properly grounded (bonded) during installation onto
the vehicle, either by solid mounting to the vehicle frame or chassis or
by means of an approved bonding conductor. DO NOT disconnect the
bonding conductor, if so equipped. DO NOT reconnect the bonding con­
ductor to any generator part that might be renKtved or disasserffeled during
routine maintenance. If the grounding conductor must be replaced, use
only a flexfele conductor that is of No. 8 AWG copper wire minimum.
• Keep hands, feet clothing, etc., away from drive belts, fans and other
moving parts of this equipment Never remove any drive belt or fan
^ards while the unit fe operating.
• Inspect the generator periodically. Repair or replace all damaged or
defective parts immediately.
A In case of accident caused by electric shock, shut down the source
of electrical power at once. If this cannot be done, free victim from live
conductor. AVOID DIRECT CONTACT WITH THE VICTIM. Use a dry
board, dry rope, or other non-conducting implement to free the victim
from live conductor. If victim Is unconscious, apply first aid and get
medical help.
• Inspect fuel system frequently for leaks or damage. Repair or replace
any damaged or leaking component immediately. Never attempt to
change, alter or modify the generator fuel system in any way that mi^
affect safety or compliance with applicable codes and standards.
A The generator engine gives off DEADLY carbon monoxide gas through
its exhaust system. This dangerous gas, if breathed in sufficient con­
centrations, can cause unconsdousness or even death. This exhaust
system must have been properly installed, in strict compliance with
applicable codes and standards. Following installation, you must do
nothing that nnight render the system unsafe or in non-compliance with
such codes and standards. The generator compartment must be com­
pletely vapor sealed from vehide Interior. There must be no possibility
of exhaust fumes entering the vehicle interior. Never operate this
equipment with a leaking or defedive exhaust system.
• Never use the generator or any of its parts as a step. Stepping on the
unit can stress and break parts and may result in dangerous operating
conditions from leaking exhaust gases, fuel leakage, oil leakage, etc.
• Do not smoke around the generator. Wipe 14 ) any fuel, or oil spills imme­
diately. Never leave dly or fuel soated rags in the generator compartment
or on the generator itself. Keep the area around the generator dean and
free of debris.
• Adequate ventilation is required to expel toxic fumes and fuel vapors from
the generator compartment Do not alter the installation of this equip­
ment in any manner that might obstruct air and ventilation openings. Such
openings must be kept dear and unobstructed.
Some generators may use LP gas (propane) as a fuel. LP gas is highly
EXPLOSIVE. The gas Is heavier than air and tends to settle In low
areas where even the slightest spark can ignite the gas and cause an
explosion.
• Before performing any maintenance on the generator set disconnect its
battery cables to prevent accidental start if). Disconnect the cable from
the battery post indicated by a NEGATIVE, NEG or (-) first Reconnect
that cable last
R e c r e a t i o n a l V e h i c l e G e n e r a t o r