Winco 75FPTOC-17 - Manual (Page 3)

Page 1 60706-125 7315-000
SAFETY INFORMATION
This generator set has been designed and manufactured to
allow safe, reliable performance. Poor maintenance,
improper or careless use can result in potential deadly
hazards; from electrical shock, exhaust gas asphyxiation, or
fire. Please read all safety instructions carefully before
installation or use. Keep these instructions handy for future
reference. Take special note and follow all warnings on the
unit labels and in the manuals.
ANSI SAFETY DEFINITIONS
______________________________________________________
DANGER:
DANGER indicates an imminently hazardous situation which,
if not avoided, will result in death or serious injury. This signal
word is to be limited to the most extreme situations.
______________________________________________________
______________________________________________________
WARNING:
WARNING indicates a potentially hazardous situation which, if
not avoided, could result in death or serious injury.
______________________________________________________
______________________________________________________
CAUTION:
CAUTION indicates a potentially hazardous situation
which, if not avoided, may result in minor or moderate injury. It
may also be used to alert against unsafe practices.
______________________________________________________
NOTE:
CAUTION is also used on the unit labels and in this
manual to indicate a situation that could result in serious
damage or destruction of the equipment and possible
personal injury.
______________________________________________________
1. ELECTRIC SHOCK- The output voltage present in this
equipment can cause a fatal electric shock. This equipment
must be operated by a responsible person.
a. Do not allow anyone to operate the generator
without proper instruction.
b. Guard against electric shock.
c. Avoid contact with live terminals or receptacles.
d. Use extreme care if operating this unit in rain or
snow.
e. Use only three-prong grounded plugs and
extension cords.
f. Be sure the unit is properly grounded to an
external ground rod driven into the earth.
g. Do not make or break electrical connection under
load.
2. FIRE HAZARD- Gasoline, diesel and other fuels always
present a hazard of possible explosion and/or fire.
a. Keep a fire extinguisher nearby and know its
proper use. Fire extinguishers rated ABC by
NFPA are appropriate.
3. DEADLY EXHAUST GAS - Exhaust fumes from any engine
contain carbon monoxide, an invisible, odorless and deadly
gas that must be mixed with fresh air.
a. Operate only in well ventilated areas.
b. Never operate indoors.
4. NOISE HAZARD - Excessive noise is not only tiring, but
continual exposure can lead to loss of hearing.
a. Use hearing protection equipment when
working around this equipment for long periods of time.
b. Keep your neighbors in mind when permanently
installing this equipment.
5. CLEANLINESS- Keep the generator and surrounding area
clean.
a. Remove all grease, ice, snow or materials that
create slippery conditions around the unit.
b. Remove any rags or other material that could
create potential fire hazards.
6. SERVICING EQUIPMENT- All service, including the
installation or replacement of service parts, should be
performed only by a qualified technician.
a. Use only factory approved repair parts.
b. Do not work on this equipment when fatigued.
c. Use extreme caution when working on electrical
components. High output voltages from this equipment
can cause serious injury or death.
d. Always avoid hot mufflers, exhaust manifolds, and
engine parts. They all can cause severe burns instantly.
7. INSTALLATION- Installing a PTO generator is not a “do-it-
yourself” project. Consult a qualified, licensed electrician or
contractor. The installation must comply with all national,
state,
and local codes.
a. Never operate the PTO drive generator without having
it properly mounted to a concrete base or approved trailer.
b. Never connect the PTO generator to an existing
electrical system without installing an isolation transfer switch.
c. Always insure the drive shaft is straight and level
before operating the generator.
8. OPERATION - PTO drive shafts (Tumbling Bars) have
many inherent dangers, extereme caution must be exercised
when using them.
a. NEVER allow children around a drive shaft when it is
in operation.
b. Keep all safety guards and shields in place and
securely tightened.
c. Never operate a drive shaft that has been damaged
or had the safety shield removed.
d. Never step over a drive shaft while it is running.
e. Never wear a necktie, loose articles of clothing, or
anything else that can be caught in moving parts.
f. Never try to stop a turndrive shaft with your hand or
your foot.