Coleman 5080A751 - Manual (Page 3)

ENGLISH
CONTENTS SECTION PAGE
General Safety Information . . . . . . . . . . . . . . . . . . . . . 2 ,3
Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . 4
Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Theory of Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Propane Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 , 6
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 8
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
GENERAL
SAFETY
INFORMATION
Continued
3
Make sure adequate ventilation is provided. Provide a fresh outside air opening at
least six (6) square feet or its equivalent, i.e., 2' x 3' for each heating unit. DO NOT USE
THIS HEATER IN LIVING QUARTERS OR WHILE SLEEPING! California lists
carbon monoxide as a reproductive toxin under Proposition 65.
PROPANE GAS:
This product is fueled by propane gas. Propane gas is invisible, odorless, and
flammable. An odorant is normally added to help detect leaks and can be described as a
“rotten egg” smell. The odorant can fade over time so leaking gas is not always detectable
by smell alone.
Propane gas is heavier than air and leaking propane will sink to the lowest level
possible. It can be ignited by ignition sources including matches, lighters, sparks or open
flames of any kind many feet away from the original leak. Use only propane gas set up for
vapor withdrawal.
Propane gas should be stored and used in compliance with local ordinances and
codes or with ANSI/NFPA 58. Turn off propane when not in use.
FIRE/EXPLOSION:
During operation, this product can be a source of ignition. Keep heater area clear
and free from combustible materials, gasoline, paint thinner, cleaning solvents and other
flammable vapors and liquids. Do not use heater in areas with high dust content. Minimum
heater clearances from combustible materials: four (4) feet from the sides and six (6) feet
from the top. Keep heater at least six (6) feet away from propane tanks and keep propane
hoses away from outlet opening of the heater.
ADDITIONAL SAFETY INFORMATION:
• Never alter or modify heater, propane hose/regulator assembly or propane cylinders.
Do not attach duct work of any kind to this heater.
• Always inspect heater, propane hoses and propane cylinders before use. Do not use
if leaking propane or if damaged. Replace hoses that have excessive wear, abrasion
or cuts. Use only Coleman repair parts and Coleman propane hoses and regulator
assemblies.
• KEEP OUT OF REACH OF CHILDREN.
• Heater will remain hot up to thirty (30) minutes after being turned off.
• Operate heater only on level, stable surface.