Klein Tools FPD-5295 - Manual (Page 13)

13
C2-F
READ
OTHER
SIDE
WARNINGS
For Positioning and Limited Fall Restrict on wood poles
ONLY as defined by ASTM F887 & CSA Z259.14-01
• Always attach snap hooks to positioning D-rings on both
sides of the belt or harness with keepers facing outward.
• Never work without independent fall arrest protection if there is danger
of a fall. Use of a Secondary Adjustable Positioning Lanyard (APL)
is highly recommended when climbing past obstacles.
• When using a Secondary APL with the (WPFRD), refer to separate
instructions and warnings for proper use.
• Never attach multiple snap hooks onto a single D-ring while
actively climbing.
• Never allow WPFRD outer strap or inner strap to become
twisted before engaging D-ring.
C2-B
• Never attach multiple WPFRD’s together.
• Assume the responsibility for determining that
your WPFRD is in good condition at all times.
• Never allow WPFRD straps to come in contact with edged
or pointed tools, sharp edges , abrasive surfaces, welding;
or near a radiator, steam pipe, stove, heater, engine exhaust pipe,
or other heat source.
• Never use a Fall Restrict Equipment (FRE) straps which have
worn to the point of showing the red-colored interior plies.
WARNINGS
C3-F
READ
OTHER
SIDE
• For human support only, NOT for towing or
hoisting material.
• Never disable locking keeper on hook, punch holes
in or alter WPFRD in any way.
• Use only with belt or harness with positioning D-rings
meeting ASTM F887 standards for intended use.
• Klein strongly recommends that Klein components NOT
be interchanged with other components made by other
manufacturers, because Klein cannot guarantee that other
manufacturers’ components are free of defects in materials
or workmanship.
WARNINGS
C3-B
• Before each use check that: 1) unit is free of burns, cuts,
abrasions, kinks, knots, broken strands and excessive wear,
2) hooks, carabineer, buckle, D-rings are not distorted or cracked,
3) hook keepers are free of burrs, functioning properly, clean,
and not bent, 4) WPFRD outer and inner straps have not worn
to the point of showing the red-colored interior plies, 5) Remove
from service, destroy and discard unit if it does not pass this
inspection and replace immediately. 6) ANY UNIT WHICH HAS
SEEN FALL ARREST SERVICE SHOULD NOT BE USED AFTER
SUCH SERVICE.
• Never attempt to repair or modify any part or component of WPFRD.
WARNINGS
WARNINGS
C4-F
READ
OTHER
SIDE
• For use by properly trained professionals only.
• OPE equipment must only be used for the specific
purpose for which it is designed and intended.
• Assume the responsibility when using the Fall Restrict Equipment
(FRE) around moving machinery and electrical hazards.
• Misuse of the Fall Restrict Equipment (FRE) could result in injury or death.
• Connecting devices must be destroyed if subjected to impact loading.
• Always visually check that: 1) each snap hook freely engages
D-ring or anchorage, 2) keeper is completely closed with each use.
Never rely solely on the feel or sound of a snap hook engaging.
• Make sure each hook is positioned so that its keeper is
never load bearing.
C4-B
• Never join two snap hooks together. They are NOT
intended to be used that way, and could twist apart.
• Employer — instruct employee as to proper use
and warnings before use of equipment.
• Read, understand and follow all instructions and
cautions attached to and/or packed with this and all
occupational protective equipment before each use.
WARNINGS
C11-F
READ
OTHER
SIDE
MODEL: FPD – 5295
DATE:
Wood Pole Diameter Range:
8" to 16" (203 mm to 406 mm)
Questions? Call TOLL FREE 1-800-553-4676
Klein Tools, Inc.
Made in the U.S.A.
Z259.14-01
Type A Fall Restrict Device. DO NOT USE ON ICY POLES.
ASTM F-887; CSA Z259.12; OSHA 1910, 1926
PRODUCT ID
C11-B
DO NOT REMOVE TAGS
PRODUCT ID
Competent person, as defined by OSHA, must inspect equipment
every 6 months. Mark month of current year if it passes.
Remove from service if it is not inspected every
6 months; if it fails, remove and replace.
Name of User ______________________________________________
Date Into Service (Month/Year) ________________________________
Polemaster™, Klein-Lok ® , Klein-Kord ® , Softee™, Ultra- Hyde™, Klein-Gard™
YEAR JAN FEB MAR APR MAY JUNE JULY AUG SEPT OCT NOV DEC
20
20
20
20