Snorkel SL30SL-sn13300-49999 - Manual

12
FOR MORE INFORMATION
Local Distributor:
TEL: (800) 926-5438 or (559) 891-5200
FAX: (559) 896-9012
PARTS: (888) UR-PARTS
PARTSFAX: (559) 896-9244
1775 Park St., Selma, CA 93662
http://www.upright.com
60588-014
12/99 D
Safety
Rules
and
Operating
Instructions
Safety
Rules
and
Operating
Instructions
ITEM
Platform Size (Inside Toeboards)
Standard
w/ Extension
Max. Platform Capacity
Standard
w/ Extension
on Extension
Max. No. of occupants
Standard
on Extension
Height
Working Height
Max. Platform Height
Min. Platform Height
Dimensions
Weight
Overall Width
Overall Height
Overall Length
Driveable Height
Surface Speed
Platform Lowered
Platform Raised
System Voltage
Hydraulic Tank Capacity
Maximum Hydraulic System
Pressure
Hydraulic Fluid
Normal Use (>32 °F [0 °C])
Low Temp. Use
(-10 to 32 °F [-23 to 0 °C])
Lift System
Lift Speed
Platform Leveling
Power Source
Control System
Horizontal Drive
Tires
Parking Brakes
Turning Radius (inside)
Maximum Gradeability
Wheel Base
Guardrails
Toeboard
SL-26SL
67.5 in. x 141.5 in. [1.71 m x 3.59 m]
67.5 in. x 181.5 in. [1.71 m x 4.61 m]
1500 lbs. [680kg]
1500 lbs. [680kg]
500 lbs. [227 kg]
5 people
2 people
32 ft. [9.75 m]
26 ft. [7.93 m]
59 in. [1.5 m]
Kohler Gas: 6,590 lbs. [2989 kg]
Kubota Gas: 6,720 lbs. [3048 kg]
Kubota Diesel: 6,780 lbs. [3075 kg]
84 in. [2.13 m]
102.5 in. [2.60 m]
149 in. [3.79 m]
26 ft. [7.93 m]
0 to 3.1 mph [0 to 5.0 km/h]
0 to .5 mph [0 to .8 km/h]
12 Volt DC
12 Gallons [45.5 l]
2500 psi [172 bar]
ISO #46
5W-20 Motor Oil
One Single Stage Lift Cylinder
Raise, 21 sec./Lower, 32 sec.
13° Side/Side, 9° Fore/Aft
20 HP Kohler Magnum, 20 HP Kubota WG750,
20 HP Kubota D905 (Diesel)
Proportional Joystick w/Interlock
Four Wheel, Hydraulic Motors
26 x 12.00 - 12 NHS Super Terra-grip with Trac Seal
Two, Spring Applied, Hydraulic Release, Multiple Disc
13 ft. [3.96 m]
35% [19°]
100 in. [2.54 m]
43.5 in. [1.11 m] high, Fold Down with Gate
6 in. [152 mm] High
SL-30SL
67.5 in. x 166.25 in. [1.71 m x 4.22 m]
N/A
1300 lbs. [590 kg]
N/A
N/A
5 people
N/A
36 ft. [10.97 m]
30 ft. [9.14 m]
59 in. [1.5 m]
Kohler Gas: 6,900 lbs. [3130 kg]
Kubota Gas: 7,030 lbs. [3189 kg]
Kubota Diesel: 7,090 lbs. [3216 kg]
84 in. [2.13 m]
102.5 in. [2.60 m]
173 in. [4.39 m]
30 ft. [9.14 m]
0 to 3.1 mph [0 to 5.0 km/h]
0 to .5 mph [0 to .8 km/h]
12 Volt DC
12 Gallons [45.5 l]
2500 psi [172 bar]
ISO #46
5W-20 Motor Oil
One Single Stage Lift Cylinder
Raise, 24 sec./Lower, 36 sec.
13° Side/Side, 9° Fore/Aft
20 HP Kohler Magnum, 20 HP Kubota WG750,
20 HP Kubota D905 (Diesel)
Proportional Joystick Controls w/Interlock
Four Wheel, Hydraulic Motors
26 x 12.00 - 12 NHS Super Terra-grip with Trac Seal
Two, Spring Applied, Hydraulic Release, Multiple Disc
13 ft. [3.96 m]
35% [19°]
100 in. [2.54 m]
43.5 in. [1.11 m] high, Fold Down with Gate
6 in. [152 mm] High
Specifications*
Meets or exceeds all applicable requirements
of OSHA and ANSI A92.6-1999.
Refer to Service Manual for complete parts
and service information.
* Specifications subject to change without
notice.
Hot weather or heavy use may reduce
performance.
1
SL-26/30SL
SAFETY RULES
Operator Manual
SL-26/30SL
SERIAL NO. 13300 to Current
NEVER operate the machine
within ten feet of power lines.
THIS MACHINE IS NOT IN-
SULATED.
NEVER elevate or drive
elevated on uneven slopes or
soft ground or elevate the plat-
form unless the platform is level.
NEVER sit, stand or climb on
guardrail or midrail.
WARNING
All personnel shall carefully read, understand and follow all safety rules,
operating instructions and the Scaffold Industry Association’s MANUAL OF
RESPONSIBILITIES (ANSI A92.6) before operating or performing maintenance on
any UpRight aerial work platform.
Safety
Rules
and
Operating
Instructions
Safety
Rules
and
Operating
Instructions
NEVER operate the machine without first surveying the work area for surface hazards such as
holes, drop-offs, bumps and debris before operating machine.
NEVER operate the machine if all guardrails are not properly in place and secured with all fasten-
ers properly torqued.
SECURE gate across entrance after mounting platform.
NEVER use ladders or scaffolding on the platform.
NEVER attach overhanging loads or increase platform size.
LOOK up, down and around for overhead obstructions and electrical conductors.
CHECK all four tires for correct inflation. See Specifications.
DISTRIBUTE all loads evenly on the platform. See the back cover for maximum platform load.
NEVER use damaged equipment. (Contact UpRight for instructions, see toll free number on back cover.)
NEVER change operating or safety systems.
INSPECT the machine thoroughly for cracked welds, loose hardware, hydraulic leaks, damaged
control cable, loose wire connections and wheel bolts.
NEVER climb down elevating assembly with the platform elevated.
NEVER perform service on machine while platform is elevated without blocking elevating assembly.
NEVER recharge batteries near sparks or open flame; batteries that are being charged emit
highly explosive hydrogen gas.
AFTER USE secure the work platform against unauthorized use by turning key switch off and
removing key.
NEVER replace any component or part with anything other than original UpRight replacement
parts without the manufacturers consent.
California Proposition 65 Warning
Gasoline and diesel engine exhaust and some of their constituents are known to the
State of California to cause cancer, birth defects, and other reproductive harm.