Snorkel PUSH 6 ECO - Manual (Page 9)

Page 8 of 23 Pop-Up PUSH 6 ECO Operator’s Safety and Maintenance Handbook (v.0.4.0409)
Section 3
SAFETY RULES
Safety Rules
NEVER Exceed the rated capacity (Safe Working Load or SWL) of the platform
(240kgs).
NEVER Use the POP-UP PUSH 6 ECO PUSH 6 ECO as a ‘crane’ (e.g. by
suspending loads from beneath the platform).
NEVER Make any attempt to increase the working height or outreach of the
platform (e.g. by use of stepladders in the platform).
NEVER Operate the POP-UP PUSH 6 ECO PUSH 6 ECO if the bubble spirit
level is outside the marked limits.
NEVER Manoeuvre the POP-UP PUSH 6 ECO PUSH 6 ECO on an inclined
surface otherwise it may become uncontrollable.
NEVER Manoeuvre the POP-UP PUSH 6 ECO PUSH 6 ECO whilst in its
elevated position, as this may cause instability.
NEVER Manoeuvre the POP-UP PUSH 6 ECO with a person or materials in
the platform.
NEVER Enter or exit the platform unless the platform is in the lowered and
transport position.
NEVER Apply external side loads to the platform or scissor structure.
NEVER Allow persons at ground level to operate the controls whilst the
platform is occupied (unless in an emergency situation).
NEVER Operate the POP-UP PUSH 6 ECO outdoors, it has not been
designed to withstand wind loading.
ALWAYS Undertake the daily checks recommended in this handbook p.9 prior
to operation of the machine.
ALWAYS Ensure that all instructions, Safe Working Load and warning decals
are clean and legible.
ALWAYS Ensure the POP-UP PUSH 6 ECO is positioned on adequate ground
to support the weight of the machine.
ALWAYS Ensure that sufficient clearance is given if working near to live
conductors.
ALWAYS Ensure that the castor brakes have been locked before elevating the
work platform.
ALWAYS Ensure that the platform does not come into contact with fixed objects
(e.g. buildings, etc.) or moving objects (e.g. vehicles, other plant
equipment, etc.).
ALWAYS Replace any removable guard rails (e.g. close and lock access gate)
to enable full edge protection to be maintained.
ALWAYS Ensure that the load is evenly distributed within the platform.
ALWAYS Ensure the safety of persons that may enter the area around the
platform (e.g. cordon off areas to prevent persons entering the danger
area).
ALWAYS Ensure hands are kept within the confines of the handrail when
operating the machine.
ALWAYS Ensure that the area below the platform is clear of obstruction before
lowering.