Blodgett MT2136 G - Manual (Page 4)

GAS BURNER COMPONENTS
Ref. Part
No. No. Description
þ 20287 Valve, Sgl Solenoid 110/120V
M0282 Valve, Manual Gas
þ M0767 Blower Motor, Combustion w/ Control Box
þ M2383 Blower Motor, Combustion
þ M2381 Transformer, 120V to 24V
þ M2385 Relay, Time Delay
þ M6397 Pilot Burner & Ignitor Assy, Nat
M6398 Pilot Burner & Ignitor Assy, LP
M0248 Tube, Pilot Aluminum 1/4"
M10076 Burner Assy, Complete Nat
M10078 Burner Assy, Complete LP
þ M0415 Flame Sensor
M0697 Orifice, Pilot Nat
M2690 Orifice, Pilot LP
M3203 Orifice, Main Burner, Nat (MTD 29)
M1491 Orifice, Main Burner, LP (MTD 45)
M2140 Flame Tube Assy
þ M1054 Spark Box, 24V
M0595 Air Pressure Switch (All gas ovens)
þ M5495 Dual Solenoid/Pres Reg Nat 24V
þ 22190 Dual Solenoid/Pres Reg LP 24V
M3434 Conversion Kit, Nat to LP (MTD 45)
M3435 Conversion Kit, LP to Nat (MTD 29)
18612 Spring, Solenoid Valve, Nat to LP
23007 Spring, Solenoid Valve, LP to Nat
M0279 Union, 1/2 Inch Black
1949 Nipple, Pipe 1/2 x 1-3/16 Close
M0590 Nipple, Pipe 1/2 x 2-1/2
M0317 Elbow, 1/2 Inch Street 90°
597 Ell, Black 90°
17874 Ell, Black 1/2 x 3/4
CONVECTION COMPONENTS
Ref. Part
No. No. Description
þ M2871 Motor & Blower Assy., 60 HZ, CW (Qty 1)
þ M2870 Motor & Blower Assy., 60 HZ, CCW (Qty 1)
9 M2100 Nozzle Assy (Aluminum) (Qty 5)
M5288 Nozzle Assy, AB Version (S/S) (Qty 5)
M5302 Nozzle Assy, AB Version (Aluminum) (Qty 5)
M2741 Plate Assy, Air (LH & RH)
11 M7490 Air Plate, LH (R-L)
12 M7493 Air Plate, RH (R-L)
M7492 Block Off, used with M7490 & M7493
M3125 Upgrade Kit, Cooling Fan (Domestic)
M7503 Plate Assy, Air LH (L-R) Bottom
M7502 Plate Assy, Air RH (L-R) Bottom Fazoli's Only
M7501 Plate Assy, Air LH (L-R) Bottom Fazoli's Only
M7507 Plate Assy, Air RH (R-L) Bottom Fazoli's Only
M7505 Plate Assy, Air RH (L-R) Top & Middle
Fazoli's Only
M7508 Plate Assy, Air LH (R-L) Top & Middle
Fazoli's Only
M10528 Plate Assy, Air LH (L-R) Papa Johns Only
M9645 Plate Assy, Air RH (L-R) Papa Johns Only
M7217 Plate Assy, Air LH (R-L) Papa Johns Only
M10529 Plate Assy, Air RH (R-L) Papa Johns Only
M10447 Block Off, used with M10528 & M10529
NOTE: No Block Offs are used with M9445 & M7217
SEPTEMBER 6, 2001 4 MT2136 E & G
CONVEYOR COMPONENTS
SB=SINGLE BELT TB=TWIN BELT
Ref. Part
No. No. Description
þ FW502 Speed Control Board, Bodine Recond.
NOTE: M2379 is no longer available
þ M10099 Conveyor Motor & Control Kit, Brushless
(for Computerized Ovens) *See Note
þ M10246 Conveyor Motor & Control Kit, Brushless
(for Non-Computerized Ovens) *See Note
þ M10081 Conveyor Control, Brushless *See Note
þ M10082 Conveyor Motor, Brushless *See Note
NOTE: You must install the Brushless Kit BEFORE
you purchase the new brushless motor or
control separately.
M6192 Bracket, Motor Support (for M10082)
þ M3145 Potentiometer, Bodine, 10K
þ M9787 Fuse, Armature, 250 MA, 250V (Qty 1)
(Replaces M2316, DOMESTIC ONLY)
þ M2254 Fuse, Line, Bodine Board, 5 AMP, 250V
(Qty 1)
M5770 Conversion Kit, Micro-Drive
M7202 Conversion Kit, Open Loop to Closed Loop
(Computerized)
M0984 Pick-Up, PV-2 (For M6474 or M8677)
M3147 Pick-Up, PV-10 (For M3146)
M0200 Lock, Speed Control Potentiometer
M0201 Dial, Speed Control Potentiometer
21169 Knob, Speed Control Potentiometer
M2500 Brush Set, Bodine
M2738 Chain, Drive, 16"
M0391 Chain, Drive, 1.92 ft. (FAZOLI'S ONLY)
þ M0112 Masterlink, Drive Chain
18 þ M2740 Belt, Wire S/S 21" SB (Per Foot) (Total 11 FT)
18 M6336 Belt, Wire S/S 10" TB (Per Foot) (Total 21 FT)
18 þ M5289 Belt, Wire S/S 12" (Total 11 FT)
þ M5260 Belt, Wire S/S 8" (Total 11 FT)
M2388 Tensioner Assy, Belt
(Spring, Sleeve & Shaft Assy)
2 M2011 Conveyor Assy, Drive Side SB
5M2012 Conveyor Assy, Idle Side SB
M2207 Conveyor Assy, Drive Side TB
M2208 Conveyor Assy, Idle Side TB
þ M0109 Sprocket, Motor Drive, 12 Tooth SB/TB
þ M0108 Sprocket, Conveyor Belt, 11 Tooth SB/TB
(Bore Diameter 3/4" ) (Qty 1)
þ M0110 Sprocket, Conveyor Drive, 15 Tooth SB/TB
(Bore Diameter 3/4")
M1865Sprocket, Conveyor Drive, 15 Tooth TB
(Bore Diameter 1/2")
M3441 Sprocket, 19 Tooth
M0122 Bearing, Rulon for Conveyor Drive
M9216 Speed Up Kit, 22 Tooth, Fazoli's