Lincoln Electric IM745 POWER WAVE 355 - Manual (Page 9)

A-2 INSTALLATION
POWER WAVE 355
A-2
SELECT SUITABLE LOCATION
The Invertec POWER WAVE 355 will operate in harsh
environments. Even so, it is important that simple pre-
ventative measures are followed in order to assure
long life and reliable operation.
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do
not place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface
directly under stationary or fixed elec-
trical equipment, that surface shall be
covered with a steel plate at least
.06”(1.6mm) thick, which shall extend
not less than 5.90”(150mm) beyond the equipment
on all sides.
-----------------------------------------------------------------------
STACKING
POWER WAVE 355 cannot be stacked.
TILTING
Place the machine directly on a secure, level surface
or on a recommended undercarriage. The machine
may topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
Invertec POWER WAVE 355. Installation should be
made in accordance with the appropriate National
Electrical Code, all local codes and the information
detailed below.
• When received directly from the factory, multiple
voltage machines are internally connected for
460VAC. If 460VAC is the desired input, then the
machine may be connected to the power system
without any setup required inside the machine.
SAFETY PRECAUTIONS
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES,
OUTPUT CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green/yellow lead of the power
cord to ground per U.S.National Electrical
Code.
----------------------------------------------------------------------
WARNING
• Initial 200VAC - 415VAC and 575VAC operation
will require an Input voltage panel setup.
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-
230.
For higher voltages: Position the large switch to
380-575.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A 10 ft. power cord is provided and wired into the
machine. Follow the power cord connection instruc-
tions.
• Incorrect connection may result in equipment
damage.
-----------------------------------------------------------------------
Single Phase Input
Connect green lead to ground per National Electrical
Code.
Connect black and white leads to power.
Wrap red lead with tape to provide 600V insulation.
Three Phase Input
Connect green lead to ground per National Electric
Code.
Connect black, red and white leads to power.
UNDERCARRIAGE MOUNTINGS
W AR NING W AR NING
AV ISO DE PR EC AU CIO N
AT TE NT IO N
!
!
!
!
Lorem ipsu m d olo r s it a me t c ons ecte tuer adi pis cin g Lore m ip sum dolo r sit am et c ons ecte tue r ad ipis cing elit , ed dia m non elit, ed dia m non um m um my nib h e uism od t incid unt ut y n ibh eu ism od t incid unt ut laor eet d olo re m agn a a liqu am er lao ree t do lore m agn a a liqu am erata t Lor em ips um do lor s it a me t con sec tetu er a dip iscin g Lore m ip sum dolo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m non elit, ed dia m n onu mm um my nib h e uis mo d tin cid unt ut y n ibh eu ism od t incid unt ut lao ree t d olo re m agn a al iqu am er lao ree t do lore m agn a a liqu am erata t Lore m ipsu m d olor sit a me t co nse cte tue r a dip isc ing Lore m ip sum dolo r sit am et c ons ecte tue r ad ipis cing elit, ed d iam no n elit, ed dia m n onu mm um my n ibh euis mod tinc idu nt u t y n ibh eu ism od t incid unt ut lao ree t d olo re ma gna aliq uam er lao ree t do lore m agn a a liqu am era t at Lore m ips um do lor sit a me t co nse ctet uer ad ipis cin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed d iam no n elit, ed dia m n onu mm um my nibh eu ism od tinc idu nt u t y n ibh eu ism od t incid unt ut lao ree t do lore m ag na aliq uam er lao ree t do lore m agn a a liqu am era t at Lore m ip sum do lor sit a me t co nse cte tue r a dip iscin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed d iam non elit, ed dia m non um m um my n ibh euis mod tinci dun t ut y n ibh eu ism od t incid unt ut lao ree t do lore m agn a a liqua m e r lao ree t do lore ma gna aliq uam era t at Lore m ipsu m dol or s it a me t co nse cte tue r ad ipis cin g Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m non elit, ed dia m n onu mm um my nib h e uis mo d tin cidu nt u t y n ibh eu ism od t incid unt ut la ore et d olo re ma gna aliq uam er lao ree t do lore m agn a a liqu am era t at Lore m ips um dolo r s it a met co nse cte tuer adip iscin g Lore m ip sum dolo r sit am et c ons ecte tue r ad ipis cing elit , ed dia m non elit, ed dia m n onu mm um my nib h e uismo d tin cidu nt u t y n ibh eu ism od t incid unt ut lao ree t do lore m ag na aliq uam er lao ree t do lore ma gna aliq uam erata t Lor em ipsu m dol or s it a me t co nse cte tue r a dip isc ing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m no n elit, ed d iam no num m um my nib h e uis mo d tin cid unt u t y n ibh eu ism od t incid unt ut lao reet dolo re ma gna aliq uam er lao ree t do lore m agn a a liqu am era t at Lorem ipsu m d olo r si t am et c ons ec tetu er a dip iscing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit , ed dia m non elit, ed dia m non um m um my nib h e uis mo d tin cid unt u t y n ibh eu ism od t incid unt ut lao ree t d olor e m agn a a liqu am er lao ree t do lore m agn a a liqu am era t at
Lore m ip sum do lor sit a me t co nse ctet uer adip isc ing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, e d d iam non elit, ed d iam no num m um my n ibh euis mo d tin cidu nt u t y n ibh eu ism od t incid unt ut lao ree t d olo re m ag na a liqu am er lao ree t do lore m agn a a liqu am era t at Lorem ips um do lor sit a me t co nse cte tue r ad ipis cing Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit , e d d iam no n elit, ed d iam no num m um my nib h e uism od tinc idu nt u t y n ibh eu ism od tinc idu nt u t lao ree t d olo re m agna aliqu am er lao ree t do lore m agn a a liqu am era t at Lorem ips um dolo r s it a me t con sec tetu er adip iscin g Lore m ipsu m d olo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m non elit, ed dia m n onu mm um my n ibh eui sm od tin cidu nt u t y n ibh eu ism od t incid unt ut laore et d olo re m ag na aliq uam er lao ree t do lore ma gna aliq uam era t at Lore m ipsu m d olo r s it a me t co nse cte tue r a dip iscin g Lor em ipsu m d olo r sit am et c ons ecte tue r ad ipis cing elit, ed dia m no n elit, ed dia m n onum m um my nib h eu ism od ti nc idu nt u t y n ibh eu ism od t incid unt ut laore et d olo re ma gn a a liqu am er lao ree t do lore m agn a a liqu am era t at Lore m ip sum dolo r sit am et c ons ecte tue r a dip iscin g
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m non elit, ed dia m n onu mm um my nib h e uis mo d tin cid unt u t y n ibh eu ism od t incid unt ut
lao ree t do lore m agn a a liqu am er lao ree t do lore m agn a a liqu am era t at Lore m ipsu m dolo r sit am et c ons ecte tue r ad ipis cing
Lore m ip sum do lor sit a me t co nse cte tue r ad ipis cing elit, ed dia m non elit, ed dia m non um m um my n ibh euis mo d tin cid unt u t y n ibh eu ism od t incid unt ut lao reet do lore ma gna aliq uam er lao ree t do lore ma gna aliq uam era t at Lore m ipsu m dolo r s it a me t co nse cte tue r ad ipis cin g
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing
elit, e d d iam no n elit, ed dia m non um m um my nib h e uism od tinc idu nt u t y n ibh eu ism od t incid unt ut
lao ree t do lore ma gna aliq uam er lao ree t do lore ma gna aliq uam era t at Lore m ipsu m dolo r sit am et c ons ecte tue r a dip iscin g
Lore m ip sum do lor s it a me t co nse cte tue r ad ipis cing elit, ed dia m n on elit, ed dia m n onu mm um my n ibh eu ism od tinc idu nt u t y n ibh eu ism od t incid unt ut
lao ree t do lore ma gna aliq uam er lao ree t do lore m agn a a liqu am era t at
Lorem ips um do lor sit am et c on sec tetu er a dip isci ng Lore m ip sum do lor s it a me t con sec tetu er a dip iscin g elit, ed dia m n on elit, ed dia m n onu mm um my nib h e uis mo d tin cid unt ut y n ibh eu ism od t incid unt ut lao ree t d olo re m agna aliqu am er lao ree t do lore m agn a a liqu am era t at Lo rem ipsu m dolo r sit am et c ons ect etu er a dip iscin g Lore m ip sum do lor sit a me t co nse cte tue r ad ipis cing elit, ed d iam no n elit, ed d iam no num m um my n ibh eu ism od t incid unt u t y n ibh eu ism od t incid unt ut la ore et d olo re ma gn a a liqu am er lao ree t do lore m agn a a liqu am era t at
W AR NIN G RE M OTE
PO W ER
OFF
ON
P O W E R W A V E 3 5 5
GREEN
RED
BLACK
WHITE
5.50
10.00
MOUNTING HOLE LOCATIONS
M19527
1/4-20 NUT (4 PLACES)
NOTE: MOUNTING SCREWS CA
10/01
N NOT PROTRUDE MORE THAN
0.5 INCHES INSIDE THE MACHINE.
11.84
3.50
CAUTION
CAUTION