J&M AM-2ES Auger-Mate - Manual (Page 6)

6
MAINTENANCE
The Auger-Mate pump may squeal due to the following conditions:
Low Oil Level
Oil is cold. Run the engine for 5 to 10 minutes.
Oil tank fill cap is dirty.
Large suction hose is bent or shut.
Oil filter is dirty and needs replaced. 1
2
3
4
5
Poor performance may be attributed to the following conditions and indicate immediate service.
Low Power - The relief valve on the control valve may have dirt under the ball.
Low Speed - The oil tank filler breather is dirty and needs cleaned or replaced.
Oil Level May Be Low - Fill to withing 1-1/2” of full.
Oil Filter Dirty - Replace. 1
2
3
4
INITIAL OPERATION
OPERATION
For optimum performance from your Auger-Mate, observe the following:
This Auger-Mate is designed for use with 6” hydraulic augers up to 15’ in length. For other applications (such
as operating a hydraulic cylinder in a woodsplitter) additional modification of the augermate is required. Do
NOT operate the augermate with a woodsplitter or similar application without proper modifications, as the
Auger-Mate does not have safety check valves or speed control for controlling the cylinder under load.
CAUTION
Run the Auger-Mate only in well ventilated areas due to the gasoline engine power.
Keep the Auger-Mate clean and free from fertilizer or other chemicals.
When used with fertilizer, run the auger empty at the end of each day to eliminate any moisture
packing of fertilizer. 1
2
3
Hydraulic oil leaking under pressure can penetrate skin and cause infection or other injury.
To Prevent Personal Injury:
Relieve all pressure, before disconnecting fluid lines.
Before applying pressure, make sure all connections are tight and components are in good condition.
Never use your hand to check for suspected leaks under pressure. Use a piece of cardboard or
wood for this purpose.
If injured by leaking fluid, see you doctor immediately.
Make sure that everyone is clear of equipment before applying power.
SAFETY RULES (continued)
ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED!