Camp Chef PG24 - Manual (Page 2)

1. Do NOT leave this appliance unattended while in use. The user must remain in the immediate area of the product and
have a clear view of the product at all times during operation.
2. Keep children and pets away from burner at all times.
3. The use of alcohol, prescription or non-prescription drugs may impair your ability to properly assemble or safely
operate this appliance.
4. For OUTDOOR use only. Do NOT use in a building, garage or any other enclosed area. Do NOT use in or on recreational
vehicles or boats. NEVER use this appliance as a heater.
5. Do not operate appliance under ANY overhead construction. Keep a minimum clearance of 10 feet (3 m) from the sides,
front and back of appliance to ANY construction. Keep the area clear of all combustible material and flammable liquids,
including wood, dry plants and grass, brush, paper, and canvas.
6. This product is not intended for commercial use.
7. Always allow the appliance to cool before covering with the patio cover.
8. Always cover the appliance, with patio cover (if supplied), when not in use.
9. Always unplug grill before installing patio cover.
10. Use only on level surface.
11. Make sure burner clean-out is closed before starting the grill.
12. Make sure the grease bucket is in place before starting the grill.
13. In the event of a fire the dial should be turned to shutdown, close the lid, and leave it closed until the fire goes out.
After allowing the grill to cool, follow the cleaning instructions before the next use.
14. Use only food grade hardwood pellets manufactured for use in pellet grills. Using softwood or heating pellets will
void your warranty.
15. Do not allow the hopper to run out of pellets. Pellets can be added at any time. The hopper will hold approximately 15
pounds of pellets. The pellet usage will vary greatly depending on the ambient temperature as well as
cooking temperature.
16. It is recommended that you not store pellets in the hopper for extended periods as they may absorb moisture from
the air and clog the auger.
17. Keep the lid closed during cooking. The grill is designed to cook with the lid closed.
18. Note that the cooking temperature displayed on the digital readout is measured near the cooking surface on the left
side of the grill. The actual temperature inside the cooking chamber will vary slightly throughout.
DANGER
Do not work on this grill if it is plugged in. Electric shock may occur resulting in death or serious injury.
PG24-1 (1) WA
RMING RACK
PG24-2 (1) COOKING GR
AT
E
PG24-3 (1) DRIP
TR
AY
PG24-4 (1)
HEA
T
DEFLEC
TO
R
M6 X 76 BO
LT
(1
)
PG24-5 (1) CHIMNE
Y
CA
P
ASM
PG24-6 (1) CHIMNE
Y
PG24-7 (1) CHIMNE
Y
GASKET
M6 NUT
(2)
M6 X 15 BO
LT
(2
)
M6 NUT
(2)
M6 LOCK W
ASHER (2
)
M6 FL
AT
W
ASHER (2
)
PG24-8 (1) SHEL
F
M6 X 15 BO
LT
(7
)
PG24-10 (1) BURNER PULLOU
T
PG24-9 (1) PULLOUT
KNO
B
PG24-
11
(1
)
GREASE BUCKET
PG24-12 (2) RIGH
T
LE
G
M8 X 55 BO
LT
(8
)
M8 NUT
(8)
M8 LOCK W
ASHER (8
)
M8 FL
AT
W
ASHER (8
)
PG24-13 (2)
LEFT
LE
G
PG24-14 (2) LEG PLUG
PG24-17 (1) ASH CU
P
PG24-16 (2
)
WHEEL
PG24-15 (2) WHEEL
AXL
E
M10 FL
AT
W
ASHER (2
)
M10
ACORN NU
T
(2
)
PG24-18 (1)
HANDL
E
M6 X 15 BO
LT
(2
)
PG24-19 (1)
THERMOCOUPLE PG24-20 (1)
BURNER
PG24-21 (1)
HEA
TING ROD
PG24-22 (1) AUGER PG24-23 (1) AUGER BUSHING
PG24-24 (1) AUGER MO
TO
R
PG24-25 (1) AUGER PIN W/NUT
PG24-26 (1)
BLOWER MO
TO
R
PG24-27 (1)
BLOWER IMPELLE
R
PG24-28 (1) MEA
T
PROB
E
M4.2 X 10 SCREW (4
)
PG24-29 (1)
CONTROLLE
R
PG24-30 (1)
CONTROLLER KNOB
M4.2 X 10 SCREW (2
)
PG24-31 (1)
HOPPER
ASM
PG24-32 (1)
LID
PG24-33 (1) LID ROD
PG24-34 (1)
FEED GASKET
M4.2 X 10 SCREW (4
)
PG24-35 (1)
AUGER
FA
N BOX
AS
M