Rover 51 EU - Manual (Page 16)

Powered Walk Behind Mower - CE Part No. 04016218 Rev G © Copyright 12/2006
™
13
ENGLISH
POWERSTART OPTION
Problem Possible Causes Corrective Action
Engine won’t crank • Refer to “Engine Cranks Slowly” section
items
• Faulty key switch
• Faulty starter motor on the engine
• Operator presence control
• Refer to “Engine Cranks Slowly” section items
• Replace the key switch
• Have the engine serviced at an authorised service dealer
• Activate operator presence control
• Reconnect/replace disconnected/broken cable
• Have the engine brake serviced by an authorised service agent
Engine cranks slowly • Bad electrical connections
• Faulty/flat battery
• Reconnect connections securely
• Replace faulty electrical cables
• Replace/recharge the battery
SELF PROPELLED OPTION
Problem Possible Causes Corrective Action
Transmission doesn’t
drive • Refer to “Transmission Slips Under Load”
section items
• Gearbox is damaged or seized
• Clutch Plate drive pin is broken
• Final drive sprocket roll pin is broken
• Broken/dislodged drive chain
• Broken/dislodged drive belt
• Engine drive pulley key broken
• Gear box pulley roll pin broken
• Pinion gears/pawls in the drive wheels
broken/worn
• Refer to “Transmission Slips Under Load” section items
• Replace gearbox
• Replace roll pin
• Replace roll pin
• Replace/refit drive chain
• Replace/refit drive belt
• Replace key in drive pulley
• Replace roll pin
• Replace broken/worn components
Transmission slips
under load • Drive cable damaged/disconnected/not
adjusted correctly
• No adjustment left in the drive cable
• Drive clutches damaged or worn
• Slipping drive belt
• Replace/reconnect/adjust drive cables
• Adjust drive clutches
• Replace drive cable
• Replace drive plates
• Readjust or replace the drive belts
• Replace worn drive pulley
• Replace broken belt tensioning spring
Mower doesn’t free
wheel easily when
drive is in neutral • Rear wheels jammed with foreign material
• Pawls in the rear wheels are damaged or
seized
• Bearings in wheels are seized.
• Clean out and re-lubricate rear wheels
• Replace or re-lubricate the pawls
• Replace wheels bearings
Powered Walk Behind A4 CE English.indd 16