Jaguar XK8 - Manual (Page 12)

User Instructions
11 DATE OF ISSUE: OCTOBER 1996
XK8 Range 1997
E 58
D O 1 7 53 6
54 84
I
S C 1
II 5 E
6
II 40 II 1 19 I Fig. 01.1 Fig. 01.2
Fig. 01.3
Fig. 01.4
Fig. 01.5 Fig. 02.1
E 41
XK8 Range 1997
Input Output Serial and Encoded
Communications
Signal Ground (SG) CAN (Network) SCP Network
FC14-39
FC14-73
FC14-7
O
I
FC14-41 I RW
FC14-80 NB 15
BK FC14-65
FC3AS
III
II
I
FC4-1
FC4-3
FC4-2
WO
RW
WN
1
FC4-5
BK FCS48
FC3BL
BK
250A x 2
BT68
B BT67 BT66 BT60 BT63
BT61
BT62 N
N
N
250A
N
BT80 N ST1 01.1
01.1
FC89-3 FC89-1 RU BK
EM11-6 I
02.1
02.1
BK BK FCS47
FC3BR
RU
GO EM1-15 GO EMS28 GO
GO
WR NW
WK 75
37 II
WR EM60-2
ST10
ST3
N
B
6
ST11
AN2
B AN1 AN3-1
AN3-2 B
N
PI50-2
PI50-1
SW
36 II WK
SW SW
PI1-11 EM1-14 08.1
WR
N ST2
GO
O FC22-16 EM10-6 O
Y EM10-17 Y FC22-17 D D
D
Y
D
EM2-18
EM3-8 Y FCS74
D
B+
B FC14-103
SU FC22-9 D
FC14-92 SU D
EM50 3
1
5
2
I
I
Battery; Starter; Generator Battery; Starter; Generator Fig. 03.1
BATTERY HIGH POWER PROTECTION MODULE
IGNITION SWITCH (III)
NEUTRAL SWITCH
ENGINE
CRANK
FUEL PUMP CONTROL AND IGNITION
ENGINE CONTROL MODULE
SUPPRESSION MODULE
FALSE BULKHEAD STUD CONNECTOR
ENGINE CRANKING
CONTROL
BODY PROCESSOR MODULE
KEY TRANSPONDER MODULE (OPTIONAL)
NOTE: Check market specification and/or
vehicle option specification for fitment of
Security Immobilization System.
REGULATOR
GENERATOR
STARTER RELAY †
STARTER MOTOR
SECURITY ACKNOWLEDGE
O.K. TO START
† NOTE: Early production vehicles ( ➞ VIN 003300) have connector pin numbers that differ from the volume production pin numbers shown.
Use the wire color code for pin identification on early production vehicles.
MAJOR INSTRUMENT PACK – CHARGE INDICATOR (CIRCUIT CONTINUED)
POWER
LOGIC
GLASS BREAKAGE
SECURITY
ACKNOWLEDGE
SECURITY
ACKNOWLEDGE
O.K. TO START
VARIANT: All Vehicles VIN RANGE: All DATE OF ISSUE: OCTOBER 1996
The following symbols are used to represent values for Control Module Pin Out data:
I Input O Output SG Signal Ground
D Serial and encoded communications C CAN (Network) S SCP Network
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED
FOR REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and
all components connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF. REFER TO THE FRONT OF THE BOOK FOR ILLUSTRATIONS DETAILING THE LOCATION AND IDENTIFICATION OF COMPONENTS, RELAYS,
CONNECTORS, HARNESSES, GROUNDS, VEHICLE CONTROL MODULES AND CONTROL MODULE PINS.
DATE OF ISSUE: OCTOBER 1996
B+ Battery voltage V Voltage (DC) Hz Frequency
KHz Frequency x 1000
MS Milliseconds
MV Millivolts
Fig. 03.1
COMPONENTS
Component Connector / Type / Color Location / Access BATTERY BT66 / EYELET TRUNK, RIGHT HAND SIDE BT67 / EYELET BODY PROCESSOR MODULE FC14 / 104-WAY AMP EEEC / SLATE PASSENGER SIDE FASCIA / AIRBAG BRACKET ENGINE CONTROL MODULE EM10 / 28-WAY MULTILOCK 040 / SLATE ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE EM11 / 16-WAY MULTILOCK 040 / SLATE
EM12 / 22-WAY MULTILOCK 040 / SLATE
EM13 / 34-WAY MULTILOCK 040 / SLATE
GENERATOR AN1 / EYELET ENGINE COMPARTMENT / RIGHT FRONT AN2 / EYELET
ST11 / EYELET
HIGH POWER PROTECTION MODULE BT60 / EYELET TRUNK / ADJACENT TO BATTERY BT61 / EYELET
BT62 / EYELET
BT63 / EYELET
IGNITION SWITCH (KEY-IN SWITCH) FC4 (FLYLEAD) / 8-WAY MULTILOCK 070 / WHITE STEERING COLUMN KEY TRANSPONDER MODULE FC22 / 20-WAY MULTILOCK 040 / GREEN ADJACENT TO PASSENGER SIDE FUSE BOX NEUTRAL SWITCH FC89 (FLYLEAD) / 3-WAY MULTILOCK 070 / SLATE GEAR SELECTOR ASSEMBLY REGULATOR (GENERATOR) PI50 / 3-WAY SUMITOMO 0902 / BLACK ENGINE COMPARTMENT / GENERATOR STARTER MOTOR ST2 / EYELET ENGINE BLOCK ST3 / EYELET
ST10 / EYELET
SUPPRESSION MODULE AN3 (FLYLEAD) / 2-WAY ECONOSEAL III LC/ RED ENGINE COMPARTMENT / FORWARD OF GENERATOR
RELAYS
Relay Color / Stripe Connector / Color Location / Access STARTER RELAY BROWN EM50 / BROWN RH BRAKE BOOSTER ENCLOSURE RELAYS
HARNESS-TO-HARNESS CONNECTORS
Connector Type / Color Location / Access BT80 EYELET ENGINE COMPARTMENT / FALSE BULKHEAD, RIGHT HAND SIDE EM1 20-WAY MULTILOCK 070 / WHITE ENGINE COMPARTMENT / ADJACENT TO RIGHT HAND ENCLOSURE EM2 18-WAY MULTILOCK 070 / YELLOW ENGINE COMPARTMENT / ADJACENT TO RIGHT HAND ENCLOSURE EM3 14-WAY MULTILOCK 070 / SLATE ENGINE COMPARTMENT / ADJACENT TO RIGHT HAND ENCLOSURE EM60 2-WAY ECONOSEAL III HC / BLACK ENGINE COMPARTMENT / BEHIND LEFT INNER FENDER HEAT SHIELD PI1 57-WAY SUMITOMO / BLACK ENGINE COMPARTMENT / BRACKET ON TOP OF TRANSMISSION ST1 EYELET ENGINE COMPARTMENT / FALSE BULKHEAD, RIGHT HAND SIDE
GROUNDS Ground Location / Type
BT68 BATTERY GROUND STUD FC3BR EYELET (PAIR) – RIGHT HAND LEG /LEFT HAND ‘A’ POST FC3AS EYELET (SINGLE) / LEFT HAND ‘A’ POST
CONTROL MODULE PIN OUT INFORMATION (FOLD OUT PAGE)
CONTROL MODULE PIN OUT INFORMATION
ENGINE CONTROL MODULE Pin Description Active Inactive
D EM10-17 SECURITY ACKNOWLEDGE ENCODED COMMUNICATIONS D EM10-6 OK TO START – ENCODED COMMUNICATIONS I EM11-6 ENGINE CRANK GROUND (CRANKING) B+
KEY TRANSPONDER MODULE (OPTIONAL)
Pin Description Active Inactive D FC22-9 GLASS BREAKAGE / OK TO START (ENCODED COMMUNICATION) D FC22-16 OK TO START (ENCODED COMMUNICATION) D FC22-17 SECURITY ACKNOWLEDGE (ENCODED COMMUNICATION)
User Instructions
CONTROL MODULE PIN OUT INFORMATION FIGURE NUMBER COMPONENT, RELAY, CONNECTOR AND
GROUND INFORMATION
DATE OF ISSUE
DATA PAGE
FIGURE MODEL RANGE AND YEAR TITLE FIGURE NUMBER
KEY TO REFERENCE SYMBOLS VARIANT, VIN RANGE AND DATE OF ISSUE
FIGURE PAGE