Guardian Technologies 004582-2 - Manual (Page 3)

INTRODUCTION
Thank you for purchasing this model by Generac Power Systems, Inc.
This model is a compact, high performance, air-cooled, engine driven
generator designed to supply electrical power to operate electrical
loads where no utility power is available or in place of utility due to a
power outage.
READ THIS MANUAL THOROUGHLY
If any portion of this manual is not understood, contact the nearest
Authorized Dealer for starting, operating and servicing procedures.
Throughout this publication, and on tags and decals affixed to the
generator, DANGER, WARNING, CAUTION and NOTE blocks are
used to alert personnel to special instructions about a particular
operation that may be hazardous if performed incorrectly or carelessly.
Observe them carefully. Their definitions are as follows:
DANGER
After this heading, read instructions that, if
not strictly complied with, will result in serious
personal injury, including death and/or property
damage.
After this heading, read instructions that, if not
strictly complied with, may result in serious
personal injury and/or property damage.
After this heading, read instructions that, if not
strictly complied with, could result in damage to
equipment and/or property.
NOTE:
After this heading, read explanatory statements that require
special emphasis.
These safety warnings cannot eliminate the hazards that they indicate.
Common sense and strict compliance with the special instructions
while performing the service are essential to preventing accidents.
Four commonly used safety symbols accompany the DANGER,
WARNING and CAUTION blocks. The type of information each
indicates is as follows:

This symbol points out important safety
information that, if not followed, could endanger
personal safety and/or property of others.

This symbol points out potential explosion
hazard.

This symbol points out potential fire hazard.

This symbol points out potential electrical shock
hazard.
The operator is responsible for proper and safe use of the
equipment. We strongly recommend that the operator read this
manual and thoroughly understand all instructions before using
the equipment.
We also strongly recommend instructing other users to properly
start and operate the unit. This prepares them if they need to
operate the equipment in an emergency.

Always disconnect spark plug wires and place
the wires where they cannot contact the spark
plugs to prevent accidental starting when
setting up, transporting, adjusting or making
repairs to the generator.
The generator produces dangerously high voltage that can cause
extremely hazardous electrical shock. Avoid contact with bare
wires, terminals, etc. Never permit any unqualified person to
operate or service the generator.
Never handle any kind of electrical cord or device while standing
in water, while barefoot or while hands or feet are wet. Dangerous
electrical shock will result.
The National Electric Code requires the frame and external
electrically conductive parts of the generator be properly connected
to an approved earth ground. Local electrical codes may also
require proper grounding of the generator. Consult with a local
electrician for grounding requirements in the area.
Use a ground fault circuit interrupter in any damp or highly
conductive area (such as metal decking or steel work).
Do not use worn, bare, frayed or otherwise damaged electrical
cord sets with the generator.
Operate generator only on level surfaces and where it will not be
exposed to excessive moisture, dirt, dust or corrosive vapors.
Gasoline is highly FLAMMABLE and its vapors are EXPLOSIVE.
Do not permit smoking, open flames, sparks or heat in the vicinity
while handling gasoline. Avoid spilling gasoline on a hot engine.
Comply with all laws regulating storage and handling of gasoline.
Never add fuel while unit is running.

Do not overfill the fuel tank. Always allow room
for fuel expansion. If tank is over-filled, fuel can
overflow onto a hot engine and cause FIRE or
an EXPLOSION.
Never store generator with fuel in tank where gasoline vapors
might reach an open flame, spark or pilot light (as on a furnace,
water heater or clothes dryer). FIRE or EXPLOSION may result.
Generator exhaust gases contain DEADLY carbon monoxide gas.
This dangerous gas, if breathed in sufficient concentrations, can
cause unconsciousness or even death. Operate this equipment
only in the open air where adequate ventilation is available.
Allow at least two (2) feet of clearance on all sides of generator or
damage could be done to the unit. Never operate the unit inside
any room or enclosure where the free flow of cooling air into and
out of the unit might be obstructed. Review the “Cold Weather
Operation” section.

NEVER operate the generator indoors, in an attached garage
or near an open window.
•
•
•
•
•
•
•
•
•
•
•
1