Fisher & Paykel BGB48 - Manual (Page 5)

3
IMPORTANT SAFETY NOTICE!
Certain Liquid Propane dealers may fill liquid propane cylinders for use in the grill beyond cylinder filling capacity.
This “Overfilling” may create a dangerous condition.
“Overfilled” cylinders can build up excess pressure. As a safety device, the cylinder pressure relief valve will vent
propane gas vapour to relieve this excess pressure. This vapour is combustible and therefore can be ignited. To
reduce this danger, you should take the following safety precautions:
1. When you have your cylinder filled, be sure you tell the supplier to fill it to no more than 3/4 (75%) of its total
capacity.
2. If you own or use a spare cylinder, or have a disconnected cylinder, you should NEVER store
it near or under the grill/cart unit or heat box, or near any other ignition or heat source. A
sticker with this warning is provided with the grill to remind you, your family and all others
who may use your BBQ grill of these safety precautions. Install this sticker close to your
barbeque grill in a visible location that is not exposed to the elements or extreme heat.
3. Do not store a full cylinder in direct sunlight.
WARNING!
Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. This grill is
for outdoor use only.
WARNING!
Push and hold the igniter button, turn the selected burner knob to “SEAR”. If burner does not light in 4 to 5 seconds
turn knob “OFF” and wait 5 minutes before trying again for any accumulated gas to dissipate.
WARNING:IMPORTANT!
Before each use, inspect the gas supply piping or hose prior to turning the gas “on”. If there is evidence of cuts,
wear, or abrasion, it must be replaced prior to use.
Never leave the appliance unattended during use.
■ This grill must be installed according to these
instructions and in compliance with the require-
ments of AS/NZS 5601.1:2010, local authority, gas,
electricity, and any other statutory regulations.
Failure to install the product correctly could in-
validate any warranty or liability claims.
■ Refer to AS/NZS 5601.1:2010 for pipe sizing de-
tails.
■ Begin by ensuring proper installation and servic-
ing. Follow the installation instructions within
this manual. Have your grill installed by a quali-
fied installer. Have the installer show you where
the gas supply shut-off valve is located so that
you know where and how to shut off the gas to
the grill. If you smell gas, your installer has not
done a proper job of checking for leaks. If the
connections are not perfectly sealed, you can have a small leak and therefore a faint gas smell. Finding a leak is
not a “do-it-yourself ” procedure. Some leaks can only be found with the burner control in the “ON” position and
this must be done by a qualified gas fitter.
■ Children should not be left alone or unattended in an area where the grill is being used. Never allow them to sit,
stand or play on or around the grill at any time. When in use, portions of the grill get hot enough to cause severe
burns.
■ Do not store items of interest to children around or below the grill, in the cart or masonry enclosure. Never allow
children to crawl inside a cart or enclosure.
■ Never attach or disconnect an LPG cylinder, or move or alter gas fittings when the grill is in operation or is hot.
■ Use caution when closing the hood, especially if there are children around. Check that the path of the hood is
clear, as its weight could cause injury to hands or fingers caught under it.
■ Clean and perform general maintenance on the grill twice a year. Watch for corrosion, cracks, or insect activity.
Have a qualified gas fitter check the regulator, hoses, burner ports, air shutter, and venturi/valve section carefully.
Always turn off gas at the source (cylinder or supply line) prior to inspecting parts.
SAFETY PRACTICES & PRECAUTIONS
Sticker
• Always follow lighting instructions.
• Hood must be opened before
lighting a grill burner or the
rotisserie
burner.
• Check for gas leaks before lighting.
• Never lean over an open grill when
lighting. Serious burns may result.
• Hot surfaces surrounding grill
grates could cause serious burns.
• Always leave at least 31 cm
clearance to combustibles around
the
grill.
• Never store a spare LPG cylinder
under or near this unit.
• Never fill the tank beyond 3/4 full. A
fire causing death or serious injury
may
occur.
WARNING