Losi LOSB9810 - Manual (Page 6)

Losi Li-Po Battery Pack
Warning!
Lithium Polymer (Li-Po) batteries are significantly more volatile than other rechargeable batteries used in RC applications.
Failure to read and follow these instructions and safety precautions may result in fire, personal injury and damage to
property. Losi, Horizon Hobby, Inc., its retailers, and any other representatives, assume absolutely no liability for use of
this product or failure to comply with these instructions and precautions.
If you are not prepared to accept complete liability for the purchase and/or use of this product, you are advised to
return it new and unused to the place of purchase immediately.
Never ship batteries without the expressed permission of the recipient. Batteries carrying 25% or more charge
cannot be shipped safely. Batteries which are damaged cannot be shipped safely. Damage or loss due to unsafe
shipping is the legal responsibility of the person who shipped the product.
CAUTION: This product may ignite under certain conditions. Please read all safety precautions before use.
Please call 877-504-0233 with any questions or concerns regarding this product or warranty.
Usage Guidelines, Warnings and Safety Precautions
• Li-Po batteries may explode if damaged or if disposed of improperly.
•
Always inspect batteries before charging.
•
Never charge or use a Li-Po battery or pack that shows any damage or disfigurement of any kind. Swelling is a
sign of internal damage. Any breach of protective cover, wiring or plugs is also reason to discontinue use (See
Disposal Instructions).
•
Use specific Lithium Polymer charger only. Do not use a Ni-Cd or Ni-MH charger – failure to do so may
cause a fire, which may result in personal injury and/or property damage.
• Never charge around or in the area of any flammable or combustible materials.
• Always charge Li-Po batteries in or on fire resistant materials or containers.
•
Never leave battery and charger unattended while in use. Improper charging or discharging of Li-Po
batteries could result in fire.
•
Constantly monitor the temperature of the battery pack while charging. If the battery becomes hot to the touch
discontinue charging immediately. Disconnect the battery from the charger and observe it in a safe place for at
least 15 minutes.
•
If at any time you see a battery starting to balloon or swell up, discontinue charging or using immediately.
• Lithium batteries can still ignite after at least 45 minutes due to a delayed chemical reaction. If battery is
damaged or overheats, observe the battery in a safe area outside of any building or vehicle and away from
combustible material.
•
Do not allow children to charge Li-Po battery packs.
• Do not allow children to use Li-Po batteries without adult supervision.
• Shorting the wire leads can cause fire. If you accidentally short the wires, the battery must be placed in a
safe area for observation for at least 15 minutes.
•
Never store or charge a battery pack where the temperature will go below 32 degrees Fahrenheit or above 130
degrees Fahrenheit. Extreme temperatures will damage the battery pack and may cause a fire. Battery
performance may be diminished by less extreme temperatures.
•
Any of the following may cause the battery to be damaged resulting in battery swelling, leaking, or fire:
o Bending, Folding or Dropping of battery
o Damaging the edge seal of the battery
o Taking apart the battery
o Mixing cells of differing chemistry, or types, or sizes
o Mixing cells of different ages
Crash Damage
If there are signs of smoke or overheating, DO NOT go near the battery or equipment until it has been observed from a
safe distance for at least 15 minutes. Once it is safe, remove the battery and check for damage. Dispose of damaged
batteries appropriately.
Swollen Batteries
Immediately stop using or charging. If the battery is not warm to the touch, move it to an open safe area and observe it
for at least 15 minutes. Be VERY CAREFUL when moving the batteries. Do NOT put ANY pressure on the batteries or
covering as this may cause fire.
Additional Information & Guidelines
1. Battery temperature the best indicator for safety. The Losi Li-Po Battery’s temperature should never drop below
32 degrees Fahrenheit or go above 130 degrees Fahrenheit while charging or discharging.
2. Changing plugs is NOT recommended as the process is dangerous and any error can cause immediate fire.
Improperly installed plugs can also cause fire due to shorts, reverse polarity or other improper handling which
can cause battery damage.
3. Batteries should be stored in a vented, fire resistant container. Each pack should be stored in its own locked
plastic bag within the container. The number of battery packs per container should be extremely limited to
avoid chain reactions. Storage temperatures should not fall below 32 degrees F or above 130 degrees F.