Vortech 1991-1995 5.2L/5.9L Dakota/Ram User Manual

Page 21

WARNING: Do not attempt to operate the
vehicle until ALL components are installed
and ALL operations are completed
including the final check.

ENGINEERING, INC.

15. FINAL CHECK

A. Reconnect the battery.
B. If your vehicle has gone over 10,000 miles since its last spark

plug change, you will need to change the spark plugs now
before test driving the vehicle.

C. Check all fittings, nuts, bolts and clamps for tightness. Pay

particular attention to oil and fuel lines around moving parts,
sharp edges and exhaust system parts. Make sure all wires
and lines are properly secured with clamps or tie wraps.

D. Check all fluid levels, making sure that your tank(s) is filled

with 92 octane or higher fuel before commencing test drive.

E. Start engine and allow to idle a few minutes, then shut off.
F. Recheck to be sure that no hoses, wires, etc. are near

exhaust headers or moving parts and for signs of any fluid
leakage. Check ignition timing to make sure it is set to stock
specifications before commencing test drive.

G. PLEASE TAKE SPECIAL NOTE: Operating the vehicle

without ALL the subassemblies completely and properly
installed may cause FAILURE OF MAJOR COMPONENTS.

H. Test drive the vehicle.
I.

The supercharger drive belt stretches initially and will require
adjustment between 250 and 400 miles.

J. Read the STREET SUPERCHARGER SYSTEM

OWNER'S MANUAL AND WARRANTY REGISTRATION
FORM within thirty (30) days of purchasing your supercharger
system to qualify.