Generac Power Systems 91355 - Manual (Page 2)

GENERAL SAFETY RULES
THE MANUFACTURER SUGGESTS THAT THESE “RULES” FOR SAFE OPERATION BE
COPIED AND POSTED IN POTENTIAL HAZARD AREAS OF THE RECREATIONAL VEHICLE.
SAFETY SHOULD BE STRESSED TO ALL OPERATORS AND POTENTIAL OPERATORS OF
THIS EQUIPMENT.
WARNING:
The engine exhaust from this product
contains chemicals known to the State
of Caiifornia to cause cancer, birth
defects, or other reproductive harm.
NOTICE TO INSTALLER
The Installation Instructions have been published by
Generac Corporation to aid in the installation
of the
products described in this manual. Generac assumes
that installation personnel are familiar with the proce­
dures for installing such products, or similar products
that Generac manufactures. Generac also assumes
that personnel have been trained in the recommended
installation procedures for these products and that
such training includes (a) use of common hand tools,
(b) use of special Generac tools, and (c) use of any
tools and/or equipment from other suppliers.
We could not possibly know of and advise the recre­
ational vehicle trade of all conceivable methods, proce­
dures or techniques by which to perform an installation.
We could not know of the possible hazards that might
result from each installation method, procedure or
technique. We have not undertaken any such wide
evaluation. Therefore, people who use a method, pro­
cedure or technique that Generac does not specifically
recommend must first completely satisfy themselves
that their safety, the safety of the vehicle's occupants
and the products's safety is not endangered by the
method, procedure or technique selected.
Information, illustrations, specifications, etc., contained
in this Installation Manual are based on the latest infor­
mation available at the time of publication. Every effort
has been expended to be sure that such data is both
accurate and current. However, the manufacturer
reserves the right to change, alter or otherwise improve
his product at any time without prior notice.
SAFETY RULES
Gasoline is extremely FLAMMABLE and its vapors are
EXPLOSIVE. Do not permit smoking, open flame,
sparks or any source of heat in the vicinity while han­
dling gasoline. Comply with all regulations governing
the storage and handling of gasoline.
Fuel lines must be properly installed, properly fas­
tened and free of leaks. There must be no possibility
of gasoline vapors entering vehicle interior.
You are required to install an approved, flexible,
non-conductive fuel line between the generator fuel
connection point and rigid fuel lines.
If the generator can be equipped with a liquid
propane (LP) gas fuel system, install the unit so it
complies with all codes, standards and regulations
pertaining to such systems. LP gas is highly explosive.
The gas tends to settle in low areas where even the
slightest spark can ignite it and cause an explosion.
Do not allow gas vapors to enter the vehicle.
A
A
A
Engine exhaust gases contain DEADLY carbon
monoxide gas. This dangerous gas, if breathed in suf­
ficient concentrations, can cause unconsciousness or
even death. Install the exhaust system in strict compli­
ance with applicable codes, standards and regula­
tions. There must be no possibility for exhaust gases
entering the vehicle interior and endangering people
or animals.
The generator set produces dangerously high electri­
cal voltage. Contact with bare wires, bare terminals,
etc., will result in extremely hazardous and possibly
lethal electrical shock.
All applicable electrical codes, standards and regula­
tions must be strictly complied with in the installation
and use of this equipment.
The generator must be properly grounded (bonded)
to the vehicle chassis or frame.
If the vehicle electrical circuits can be powered by any
other source of electricity (such as a "dockside"
power receptacle), there must be no possibility of
connecting the different power sources to the vehicle
circuits at the same time. The "dockside" (utility)
power source must be positively isolated from the
vehicle circuits whenever the generator is operating.
Failure to isolate the vehicle circuits from the dock-
side power supply when the generator is running
may result in damage to the generator or serious
injury or death to dockside (utility) power workers
due to backfeed of electrical energy.
Never work on the equipment while standing in
water, while barefoot, or while hands or feet are
wet. Dangerous electrical shock will result.
Jewelry conducts electricity, which can cause danger­
ous electrical shock. Remove all jewelry (such as rings,
watches, or bracelets) before working on this equip­
ment.
The generator requires an adequate flow of air for
cooling and ventilation. Without sufficient cooling air
flow, the engine-generator quickly overheats, which
causes serious damage to the generator, a fire or an
explosion. Generator air inlet and outlet openings
must be provided in strict compliance with the manu­
facturer's recommendations.
Never work on this equipment while physically or
mentally fatigued. Stay alert at all times.
Storage batteries give off EXPLOSIVE hydrogen gas
while charging. The battery used for cranking and
starting this generator should be installed in its own
ventecT compartment. Provide adequate ventilation
for the battery, to prevent explosive hydrogen gas
from accumulating.
Never insert any tool or other object through open­
ings in the generator interior, even if the unit is not
running. You might seriously injure yourself or dam­
age the equipment.
Staying alert and using "common sense" are major
measures for preventing accidents.