Sears 300.7271 - Manual

PARTS LIST
DESCRIPTION PART NO. ÛUAN.
Hardshell Top (18 ou. ft.) N/A 1
Hardshell Bottom N/A 1
Master Parts Bag 04070 1
MASTER PARTS BAG m 7Q
C^lock with Keys 03807 (R) 2
Lock Bracket 00841 (M) 2
Lock Locator 03808 (S) 2
Snap Latch 03347
Support Assembly 03810 (0) 2
Foam Gasket 01315 (A) 1
Instruction Sheet 04657 1
Small Parts Bag 04864 1
SMALL BARTS BAG (BflM
Large Flat Washer 00070 (G) e
1/4" Flatwasber 00017 (H) 2
Small Flat Washer 03666 ÎB) 4
1/4" X 20 Plastic Insert Nut 00115 (J) 10
1/4" X 20 X 5/8” Screw 04103 (E) 6
1/4” X 20 Universal Drive Screw 03948 (F) 4
#10-24x5/8’Screw 01010 (D) 4
#10-24 Plastic Insert Nut 00764 (1) 4
PRË-ASSEMBLEO ON CARRIER AT FACTORY.
Hinge 03396 (L) 2
PARTS AVAILABLE
Save this instruction sheet for future reference
when ordering replacement parts. Refer to
Model 300.7271. Replacement parts are
available through ^aars Parts Department
( 800 ) 368-7278
I
nstruction
S
he
^
A ssembly of C ar -T op C arrier
M odel
300.7271 (18 CU. FT;)
IMPORTANT - MUST READ BEFORE ASSEMBLING
Before assembling and installing the carrier please carefully read
the guidelines for Installation and use of the carrier below. Prpper
assembly and installation of the carrier Is the customer's
responsibility. The manufacturer's warranty is limited to the repair
or replacement of a defective carrier. Damage to the vehicle, the
carrier's contents, or to any perscm or property Is excluded, .
No more than 100 pounds of evenly distributed weight should
ever be transported In the carrier.
Do not travel with an empty carrier at speeds over 40 MPH. Keep
a minimum of 50 lbs. in the carrier at higher speeds to ayold
undesirable wind effects. It Is recommended to remove carmr
from vehicle when rtot in use.
AJI carrier hardware and straps must be firmly attached. When
traveling, periodically check all hardware and straps to assuré it
is fastened securely. Each time the carrier (s installed check
hardware and straps for sign of corrosion or excessive wear.
When using carrier the front and rear back latches must he
closed, and the two locks must be locked and the keys
removed. Then locking carrier be sure latches on upper,
hardshell are engaging brackets on lower hardshell befÈpié
turning- key. Top hardshell will not pull up from lower
hardshell when carrier Is properly locked.
The carrier is water resistant, not waterproof. Always protect
contents accordingly.
Do NOT place valuable or fragile items in the carrier. Sudden
stops may cause contents to shift, possible damaging valuable
or fragile items. The carrier is not designed to be acæident or
theft proof.The manufacturer and retailer cannot be held
responsible for damage to or theft of carrier's contents.
J
- - INSTALLATION OPTIONS -
I
« • If you intend to attach the Carrier to a vehicle by using.
I mounting hooks, both the mounting hooks and 7228 strap;.
kit are purchased separately. See Application Chart on store'
j display for specific vehicie fitment.
. • If you intend to attach the Carrier to a vehicle with a
I factory installed or aftermarket roofrack. you must purchase,
the U-Bolt Kit #7215 separately. See application Chart ,,on
! store display for specific vehicle fitment. Roof racks must
I have a capacity of at least 150 lbs. Consult your owner’s
■ manual for capacity
Ln • bmb p
m •mmm ■ a w a aHpa ■ ■ hm a aJ
MFO-BYKARftTTE 3737 NORTH ACORN AVENUE franklin park , ILUNOe 00131 1 . 0 OO 4 ÎARRITE
PAflTNO,«8S7 M arch . 2000