Lippert Components Hydro-Sync Slideout System User Manual
Page 16
TROUBLESHOOTING – CHECKING FOR BAD
CYLINDER
1. Retract (close) the slideout (room) completely.
2. Loosen hose from “E” (extend) port on the manifold of the Power
Unit.
WARNING-
Do not attempt to run room out with the “E” port hose loose.
The
system will experience RAPID FLUID LOSS.
3. Plug opening on manifold to prevent drawing air into the system.
4. Energize the Power Unit to retract (close) room.
5. Continue to run the room in and watch for fluid flow from hose/port
“E”. Fluid flow greater than a few drops will indicate internal cylinder
leaking (bypassing of piston seal). If there is no fluid flow, reconnect
hose to “E” port and tighten.
WARNING -
Be sure to reconnect and tighten hose at the “E” port before
attempting to extend (open) the room or the system will
experience RAPID FLUID LOSS.
Contact qualified technician if there is excessive fluid flow. The cylinder
should not be repaired in the field.
Refill the Power Unit Reservoir as recommended on page 12 of this
manual.
16
- Center Point Suspension (8 pages)
- Disc Brake System For Trailers (7 pages)
- Sealed Bearing System (2 pages)
- Super Lube (Axle) (1 page)
- Trailer Axle (Standard) (43 pages)
- Trailer Axle (8-12K) (39 pages)
- Correct Track II (8 pages)
- Shock Kit Aftermarket (4 pages)
- Solera (10 pages)
- Solera Power Awning with LED Lights OEM (4 pages)
- Solera® Manual Pull Strap Awning (10 pages)
- Solera® Manual Awning Crank Style (10 pages)
- Solera Slider (6 pages)
- Bauer NE Lock (8 pages)
- Ramp Door Patio Kit (6 pages)
- Touch Audio VD300WR (16 pages)
- Touch Audio Elite (12 pages)
- FT-UT9 (2 pages)
- FT-DR10 (2 pages)
- FT-DR8 (2 pages)
- FT-CG07 & FT-CG07S (2 pages)
- 07-10 Tundra Camper Tiedowns (3 pages)
- CBB07 Bumper Brace Installaion (2 pages)
- FM-TB Turnbuckles (1 page)
- FM-GL9 Centering Guide Locks (1 page)
- Ford Bumper Brace (2 pages)
- CA-CGL (2 pages)
- CA-FD7 (2 pages)
- CA-FU (1 page)
- CA-MT (1 page)
- CA-UR (1 page)
- Ground Control 2.0 (12 pages)
- Ground Control 2.0 (10 pages)
- Ground Control 3.0 (19 pages)
- Ground Control 3.0 (26 pages)
- Ground Control 3.0 (13 pages)
- Ground Control 3.0 Aftermarket (20 pages)
- Ground Control 3.0 OEM (15 pages)
- LCI’s Motor Home Electronic Controlled Hydraulic Leveling System Automatic Controls Addendum (4 pages)
- LCI Motorized Leveling (2009 - Present) (19 pages)
- LCI Electronic/Hydraulic Leveling & Slideout (31 pages)
- Ultra Level (12 pages)
- LCI Level-Up Motorhome Leveling (2013-present) (20 pages)
- Level-Up Motorhome Leveling (10 pages)
- Level Up (10 pages)