Pro-Link Warrior NB Plus- RTU Cleaner-Degreaser 06918 - Manual

Warrior NB Plus
NFPA/HMIS: Health -2, Flammability - 0, Reactivity - 0
Complies With USDL Safety and Health Regulations, (29 CFR 1910.200)
Material Safety Data Sheet US Department Of Labor
SECTION - 1 CHEMICAL AND COMPANY IDENTIFICATION
PRODUCT NAME: Warrior NB Plus
PRODUCT USE: Cleaner-Degreaser
PRO-LINK 510 Chapman Street, Canton, MA 02021
EMERGENCIES: 1-800-255-3924
REVISION DATE: 12/16/97
SECTION - 2 COMPOSITION ON INGREDIENTS
CAS # CHEMICAL NAMES Wt% TLV (UNITS)
9016-45-9 Nonylphenoxypolyethoxy ethanol < 8.0 N/E
N/E = not established
SECTION - 3 HAZARDS INFORMATION
Primary Route(s) of Entry: Skin contact /absorption and inhalation
Signs and Symptoms of Overexposure: Gastrointestinal irritation (nausea, vomiting,
diarrhea), irritation to nose, throat, and respiratory tract.
Target Organ Effects: None expected.
IMMEDIATE HEALTH EFFECTS
EYES: Exposure may cause noticeable pain, and severe irritation.
SKIN: Exposure may cause mild skin irritation. Prolonged or repeated exposure may
dry the skin. Symptoms may include redness, burning, and drying and cracking.
Additional symptoms of skin contact may include: allergic reaction. Skin absorption is
possible, but harmful effects are not expected from this route of exposure under normal
handling and use.
INHALATION: Exposure to vapor or mist is possible. Short-term inhalation is no likely
to cause harmful effects: breathing large amounts may be harmful. Symptoms are
more typically seen at air concentrations exceeding the recommended exposure limits.
INGESTION: Single dose oral toxicity is low. Swallowing small amounts during normal
handling is not likely to cause harmful effects: swallowing large amounts may be
harmful.
REPRODUCTIVE / DEVELOPMENTAL INFORMATION: No Data
CARCINOGENIC INFORMATION: This material is not listed as a carcinogen by IARC,
NTP, or OSHA
LONG TERM EFFECTS: No Data
SECTION - 4 FIRST AID MEASURES
EYES- Immediately flush with water. Remove contact lenses if applicable, and
continue flushing with water. Call a physician if irritation persists.
SKIN- Flush with water. Wash thoroughly with soap and water. Call physician if
irritation persists.
INHALATION- If symptoms develop, move victim to fresh air. If symptoms persist call
a physician.
INGESTION- Do not induce vomiting. Rinse mouth with water, then drink one glass of
water. Call a physician immediately. Never give anything by mouth if victim is
unconscious, is rapidly losing consciousness or is convulsing.
SECTION - 5 FIRE FIGHTING MEASURES
Flash Point No Flash at Boil (C.C. method)
Explosive limits Not Applicable
Autoignition Temperature Not Applicable
Hazardous Products of Combustion Not Applicable
Extinguishing Media Not Applicable
Fire Fighting Instructions: Avoid contact with this material. Avoid walking in spilled
material. Wear protective clothing for skin and eyes
SECTION - 6 ACCIDENTAL RELEASE MEASURES
Small Spill: Absorb with an inert solid and scoop up for disposal, then rinse soiled
area with water down the drain.
Large Spill: Stop leak at the source and collect into a suitable container, then treat as
a small spill.
SECTION - 7 HANDLING AND STORAGE
Handling: Containers of this material may be hazardous when emptied. Since
emptied containers retain product residues (vapor, liquid, and/or solid), all hazard
precautions given in the data sheet must be observed.
Storage: Store in a cool, dry place. Keep container closed when not in use.
SECTION - 8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Chemical Splash goggle in compliance with OSHA regulations are
advised: however, OSHA regulations also permit other type safety glasses. Consult
your safety representative.
Skin Protection: Wear rubber gloves (consult your safety equipment supplier). To
prevent repeated or prolonged skin contact, wear impervious clothing and boots.
Respiratory Protection: If workplace exposure limits of product or any component are
exceeded (see exposure guidelines), NIOSH/OSHA approved air supplied respirator is
advised in the absence of proper environmental control. OSHA relations also permit
other NIOSH/OSHA respirators (negative pressure type) under specific conditions (see
your industrial hygienist). Engineering or administrative controls should be
implemented to reduce exposure.
Engineering Controls: Provide sufficient mechanical (general and local exhaust)
ventilation to maintain exposure below level of overexposure (from known, suspected
or apparent adverse effects).
SECTION - 9 PHYSICAL AND CHEMICAL PROPERTIES
Appearance and odor: Thin, blue liquid with a pleasant odor
pH Concentrate: 11.5 - 12.5
Vapor Pressure: Unknown
Vapor Density: Unknown
Boiling Point: 212 Degrees Fahrenheit Solubility in Water: Complete
Percent Volatile: 90% Specific Gravity: (H2O =1) 1.01 +/- 0.02
SECTION - 10 STABILITY AND REACTIVITY
Chemical Stability: Stable
Conditions to Avoid: Temperature Extremes
Incompatibility: None
Hazardous Decomposition: Will not occur
Hazardous Polymerization: Will not occur
SECTION - 11 TOXICOLOGICAL INFORMATION
No Data Available
SECTION - 12 ECOLOGICAL INFORMATION
No Data Available
SECTION - 13 DISPOSAL CONSIDERATION
Waste Disposal Information: Dispose of in accordance with all applicable Federal,
State, and Local regulations.
RCRA Information: If this material becomes a waste, it would not be considered
hazardous under 40 CFR 261.22.
SECTION - 14 TRANSPORT INFORMATION
DOT Information 49 CFR 172.101
DOT Description:
33440 Class 55
DOT Hazard Class: Non Hazardous
Hazardous Component: None
Reportable Quantity (RQ) - 49 CFR 172.101: Not Applicable
SECTION - 15 REGULATORY INFORMATION
US Federal Regulations
TSCA (Toxic Substances Control Act) Status
TSCA (United States) The intentional ingredients of this product are listed.
CERCLA RQ - 40 CFR 355 Appendix A: None
SARA 302 Components 40 CFR Appendix A: None
Section 311/312 Hazard Class 40 CFR 370.2
Immediate (X) Delayed (X) Fire ( ) Reactivity ( ) Sudden Release of Pressure ( )
SARA 313 Components - 40 CFR 372
State and Local Regulations
California Proposition 65:
None
California SCAQMD Rule 443.1 VOC’s: None
North Carolina Administrative Code 2D.1104 and 2B.0610: None
South Carolina Regulation 62.5 Standard Number 8: None
SECTION - 16 OTHER INFORMATION
The information accumulated herein is believed to be accurate but is not warranted to
be whether originating with the company or not. Recipients are advised to confirm in
advance of need that the information is current, applicable and suitable to their
circumstances.
This information was compiled from current manufacturer’s MSDS’s of the component
parts of the product. as well as other sources, such as:
Code of Federal Regulations 29, Revised as of July 1. 1994.
Code of Federal Regulations 40, Revised as of July 1, 1994.
ACGIH, Guide to Occupational Exposure Values, 1996.
ANSI Z129.1-1994, Precautionary Labeling for Hazardous Industrial Chemicals.
Hazard Communication Handbook, A Right To Know Compliance Guide. Craig A.
Moyer & Michael Francis. Clark Broadman Company. Ltd. New York, NY 1992
RCRA Regulations and Keyword Index, Compiled and Published by McCoy and
Associates, Inc Lakewood, Colorado. 1992.