Pro-Link Fast Break B14112 - Manual

SSP MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 1/09 Revision: n/a
n/a
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Super Strip Plus
Generic Name: Extra Duty Stripper
Chemical Family: Alkaline Detergent Blend
Formula: Proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
2-Butoxyethanol 111-76-2 10 to 15 25 ppm 25 ppm
Monoethanolamine 141-43-5 5 to 10 3 ppm 3 ppm 6 ppm
Potassium Tall Oil Soap 61790-44-1 0 to 5
Nonionic Surfactant 9016-45-9 0 to 5
Sodium Silicate 1344-09-8 0 to 5
Tetrasodium Pyrophosphate 7722-88-5 0 to 5
Tetrasodium EDTA 64-02-8 0 to 5
Perfume Oils N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 215 F. Specific Gravity: 1.027
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 90+ pH: 12.3-12.8
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin liquid with characteristic odor.
Flash Point (Method Used): None
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: None Required
Special Firefighting Procedures: Non Flammable
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.
SECTION 6-STORAGE AND HANDLING INFORMATION
Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when applying to floor. Keep container closed during storage. For
institutional and industrial use only. Avoid contact with eyes, skin and clothing. Wear protective gloves, eyewear and rubber boots when handling concentrate and diluted material.
Avoid breathing of vapors. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Skin irritant. May cause moderate reddening and swelling.
Eyes: Eye irritant. Liquid and mists may damage eyes, causing corneal damage.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose,
throat, and lungs.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, nausea,
abdominal pain, vomiting, and diarrhea. Excessive amounts may cause collapse.
Respiratory Protection: Use in well-ventilated area. NIOSH Approved Organic vapor
respirator when using in confined or poorly ventilated areas.
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
gredients below acceptable limit.
Protective Gloves: Chemical resistant rubber or neoprene.
Eye Protection: Chemical splash goggles or full-face shield.
Other Protective Equipment: Eyewash station should be nearby. Protective footwear
(rubber boots) and outerwear should be worn when using product on floor.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Avoid contact with
eyes, skin, and clothing.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention
immediately.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Ventilate areas
well. Mop up or otherwise absorb and hold disposal. Avoid discharge to sewer or open
waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Best method is to recycle or reuse for intended purpose. Consult local authorities for
disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground.
Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
111-76-2 2-Butoxyethanol (Glycol Ether) 10.0%
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Fast Break