Pro-Link #12 Blitz Cleaner & Degreaser B14209 - Manual

LF6 MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 3/12 Revision: n/a
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Supplier’s Name:
Misco Products Corporation
Supplier’s Address:
Reading, PA
Supplier’s Phone #:
(610) 926-4106
Product Name: High Performance Degreaser
Generic Name: Heavy Duty Cleaner Degreaser
Chemical Family: Detergent Blend
Formula: Proprietary
HMIS Hazardous Materials Identification System
(Ready-to-Use product ONLY)
Health - 1
Flammability - 0
Reactivity – 0
Protection - A
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Dipropylene Glycol Methyl Ether 34590-94-8 10 to 15 N/A N/A N/A
2-butoxyethanol 111-76-2 5 to 10 25ppm 25ppm 50ppm
NonIonic Surfactant 9016-45-9 5 to 10 N/A
Sodium Metasilicate Pentahydrate
Sodium Xylene Sulfonate
6834-92-0
1300-72-7
0 to 5
0 to 5
N/A
N/A
Tetrasodium EDTA
Potassium Hydroxide
64-02-8
1310-58-3
0 to 5
0 to 5
N/A
2mg/m 3 2mg/m 3 2mg/m 3
Dye N/A 0 to 5 N/A
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 212 F. Specific Gravity: 1.074
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 70+ pH: 13.0 – 14.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin purple liquid with characteristic odor.
Flash Point (Method Used): None (TCC)
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: CO
2
, Dry Foam, Water Mist
Special Firefighting Procedures: Use self-contained breathing apparatus
in confined areas.
Unusual Fire and Explosion Hazards: Keep fire exposed containers cool
with water to prevent bursting.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER: Corrosive. Severe Eye and Skin Irritant. Avoid contact with eyes, skin and clothing. Wash thoroughly after handling. Avoid breathing of vapors or mists. Use
in well-ventilated area. Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial use only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Severe skin irritant. May cause moderate reddening with prolonged contact
Eyes: Corrosive. Eye irritant. Liquid and mists may damage eyes, causing corneal
damage.
Inhalation: Mists may be irritating to mucous membranes in the nose, throat, and
lungs.
Ingestion: Irritating to the mouth and throat. May cause headache, nausea,
abdominal pain, and diarrhea. Excessive amounts may cause collapse.
Respiratory Protection: Use in well-ventilated area.
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2
ingredients below acceptable limit.
Protective Gloves: Chemical resistant rubber or neoprene.
Eye Protection: Safety glasses or chemical splash goggles.
Other Protective Equipment: Eyewash station provided nearby.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention if irritation persists.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Ventilate area well. Keep unessential
personnel away. Mop up or otherwise absorb and hold disposal. Avoid discharge
to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. If discarded, this
material and containers should be treated as hazardous waste based on the
characteristic of corrosivity as defined under federal RCRA regulations (40 CFR
261). Consult local authorities for disposal in public sewer. Do not dispose of into
storm drain, stream, river or to ground. Rinse container thoroughly before
discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (Potassium Hydroxide), 8, NA-1760, PG III Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: Cleaning Compound LQ Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
111-76-2 2-butoxyethanol (glycol ether) 7% max.
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from
the improper handling and use of this product
REVISION: 3/16/12- Revised Sec. 10 Shipping Information
Blitz
Supplier’s Name: Pro-Link, Inc.
Supplier’s Address: Canton, MA 02021
Supplier’s Phone: 1-800-74-LINKS