Pro-Link BioBlitz B14178 - Manual

E20 MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 4/11 Revision: n/a
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Bio Solvent Degreaser
Generic Name: Soy Solvent
Chemical Family: Solvent/Detergent Blend
Formula: proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Soy Oil Methyl Ester 67784-80-9 40 to 50
Coconut Diethanolamide 8051-30-7 5 to 10
Monoethanolamine 141-43-5 0 to 5
Ethoxylated Alcohol Surfactant 34398-01-1 5 to 10
Benzyl Alcohol 100-51-6 20 to 30
Ethyl Lactate 97-64-3 20 to 30
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°°°°F): 335 F. Initial Specific Gravity: .0.930 – 0.960
Vapor Pressure: 1.2 mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 25+ pH: 9.0 – 10.0
Solubility in Water: Emulsifies Evaporation Rate (Water=1): <1
VOC Content Information: % VOC = < 23.0
Physical Description: Thin amber liquid with characteristic odor.
Flash Point (Method Used): 123° F. (TCC)
Upper Explosion Limit: 12.0 Lower Explosion Limit: 1.0
Extinguishing Media: Foam, CO
2
, or Dry Chemical
Special Firefighting Procedures: Do Not Use Water.
Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Carbon monoxide possible if burned. Incompatibility (Materials to Avoid): None known.
SECTION 6-STORAGE AND HANDLING INFORMATION
WARNING: Eye and skin irritant. Avoid contact with eyes, skin and clothing. Wear rubber gloves and protective eyewear when handling concentrate or diluted product.
Avoid breathing of vapors. Use in well-ventilated area. Combustible liquid – Avoid contact with heat, spark or open flame. Keep out of reach of children. For use by trained
personnel only. Wash hands thoroughly with soap and water after handling. Keep container closed during storage. For institutional and industrial use only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Irritant. Defatting to skin with prolonged or repeated contact. May lead to
dryness and irritation.
Eyes: Eye irritant. May cause redness, burning, or tearing.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose,
throat, and lungs.
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system.
Respiratory Protection: Use in well-ventilated area.
Ventilation Requirements: Explosion-proof mechanical fans when used in
confined or poorly ventilated areas.
Protective Gloves: Chemical resistant rubber or neoprene.
Eye Protection: Safety glasses or chemical splash goggles.
Other Protective Equipment: Eyewash station nearby. Rubber boots when using
on floors.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention if irritation persists.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Extinguish all ignition
sources and ventilate are well. Floors will become slippery. Avoid walking in
product. Keep unessential personnel away. Mop up or otherwise absorb and hold
disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. If discarded, this
material and containers should be treated as hazardous waste based on the
characteristic of ignitability as defined under federal RCRA regulations (40 CFR
261). Consult local authorities for disposal in public sewer. Do not dispose of into
storm drain, stream, river or to ground. Rinse container thoroughly before
discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
Yes - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 2
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection C
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of
1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application
of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe
workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper
handling and use of this product
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Bio Blitz