Pro-Link Broadband Q256 Neutral Disinfectant & Detergent B14228 - Manual

256 MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 6/12 Revision: N/A
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Hi-Con 256
Generic Name: Neutral Disinfectant & Detergent
Chemical Family: Quaternary Detergent Blend
Formula: Proprietary
EPA Reg. No.: 10324-141-8325
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
n-Alkyl Dimethyl Benzyl Ammonium Chloride 8001-54-5 6.76
Didecyl Dimethyl Ammonium Chloride 7173-51-5 10.14
Nonylphenol Ethoxylate 9016-45-9 0 to 5
Tetrasodium salt of EDTA 64-02-8 0 to 5
Perfume Oils N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 210 F. Specific Gravity: 1.01
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 80+ pH: 6.0 – 8.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin liquid with characteristic odor.
Flash Point (Method Used): None
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: N/A
Special Firefighting Procedures: Non Flammable.
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Thermal decomposition may produce toxic
vapors/fumes of hydrogen chloride, amines, and oxides of carbon and nitrogen
Incompatibility (Materials to Avoid): Strong oxidizing or reducing agents
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER: KEEP OUT OF REACH OF CHILDREN. Corrosive. Causes irreversible eye damage and skin burns. Harmful if swallowed, inhaled or absorbed through
the skin. Avoid breathing spray mist. Do not get in eyes, on skin, or on clothing. Wear goggles or face shield, rubber gloves and protective clothing when handling. Wash
thoroughly with soap and water after handling and before eating, drinking, or using tobacco. Remove contaminated clothing and wash clothing before reuse.
EPA registered product, follow direction exactly. Avoid breathing of mists. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Severe skin irritant. Prolonged or repeated contact may burns and/or
irreversible damage.
Eyes: Severe eye irritant. Liquid and mists may injure the eyes, causing corneal
burns/damage.
Inhalation: N/A
Ingestion: Irritating to the mouth, throat, and gastrointestinal system. Burning,
pain, severe swelling of larynx; skeletal muscle paralysis, drowsiness.
Respiratory Protection: No special requirements.
Ventilation Requirements: No special requirements.
Protective Gloves: Chemical resistant rubber or neoprene.
Eye Protection: Chemical splash goggles or full-face shield.
Other Protective Equipment: Eyewash station should be provided nearby. Wear
protective rubber footwear when using on floors.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Remove contaminated clothing. Immediately flush affected areas with large
quantities of water. Seek medical attention if irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open, for at least 15
minutes. Seek medical attention immediately.
Inhalation: Remove to fresh air and monitor. Seek medical attention.
Ingestion: Give large quantities of milk or water. Do not induce vomiting. Seek
medical attention immediately.
Note to Physician: Probable mucosal damage may contraindicate the use of gastric
lavage. Supplemental oxygen and other measures to support breathing may be
needed to combat circulatory shock.
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: EPA registered pesticide. Any method in accordance
with local, state and federal laws governing such. Best method is to recycle or reuse
for intended purpose. Consult local authorities for disposal in public sewer. Do not
dispose of into storm drain, stream, river or to ground. Triple rinse container
thoroughly before discarding in trash. See container label for additional
instructions.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Corrosive liquid, basic, Organic, Identification System
No - Sudden Release of Pressure Hazard N.O.S. (Quaternary Ammonium Compound), 8, UN3267, PGIII Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound LQ Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound LQ Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this information,
or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the health and safety
information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Broadband Q256