Pro-Link Value Pro Acid Bowl Cleaner 166392 - Manual

1
Value Pro
Acid Bowl Cleaner
NFPA/HMIS : Health - 2
Flammability - 0
Reactivity - 0
Complies With USDL Safety and Health Regulations, (29 CFR
1910.200)
Material Safety Data Sheet US Department Of Labor
SECTION - 1 CHEMICAL AND COMPANY
IDENTIFICATION
PRODUCT USE: Acid Cleaner
American Formula
P.O. BOX 43164
Atlanta, GA 30336
EMERGENCIES: 1-800-255-3924
REVISION DATE: 10/30/03
SECTION - 2 COMPOSITION ON INGREDIENTS
CAS # CHEMICAL NAMES Wt% TLV (UNITS)
7647-01-0 Hydrochloric Acid 5% 5ppm
SECTION - 3 HAZARDS INFORMATION
Primary Route(s) of Entry Skin contact and inhalation
Signs and Symptoms of Overexposure Gastrointestinal irritation
(nausea, vomiting, diarrhea), irritation to nose, throat, and respiratory
tract.
Target Organ Effects Overexposure to this material (or its
components) has been suggested as a cause of the following effects in
laboratory animals and may aggravate pre-existing disorders or these
organs in humans: chronic ingestion may cause kidney and liver
lesions at high doses.
IMMEDIATE HEALTH EFFECTS
EYES Corrosive. Vapors are irritating and may cause damage to eyes.
Contact may cause severe burns and permanent eye damage
SKIN Corrosive. Causes chemical burns. Harmful contact may not
cause immediate pain.
INHALATION Corrosive! Inhalation of vapors can cause coughing,
choking, inflammation of the nose, throat, and upper respiratory tract,
and in severe cases, pulmonary edema, circulatory failure, and death.
INGESTION Corrosive! Harmful or fatal if swallowed. Causes
chemical burns to the mouth, throat and stomach.
REPRODUCTIVE / DEVELOPMENTAL INFORMATION
No Data
CARCINOGENIC INFORMATION This material is not listed as a
carcinogen by IARC, NTP, or OSHA
LONG TERM EFFECTS Long term exposure to concentrated vapor
may cause erosion of teeth. Long term exposure seldom occur due to
the corrosive properties of the acid.
SECTION - 4 FIRST AID MEASURES
FIRST AID:
SWALLOWED: Rinse mouth with water. Drink a glassful of water or
milk. Do not induce vomiting. Call physician immediately. Drink large
quantities of water. Never give anything by mouth to an unconscious
person.
EYES: Rinse immediately with water. Quickly remove contact lenses;
then flush eyes with water for 15 minutes.
SKIN: Remove contaminated clothing. Flush skin with water for 15
minutes. Then, Call Poison control center or physician at once.
SECTION - 5 FIRE FIGHTING MEASURES
Flash Point Explosive limits
No Flash at Boil (C.C. method) Not Applicable
Autoignition Temperature Hazardous Products of
Combustion
Not Applicable Chlorine gas and hydrogen
chloride
Extinguishing Media Fire Fighting Instructions
Not Applicable Avoid contact with this material.
Avoid walking in spilled material.
Wear protective clothing for skin
and eyes
SECTION - 6 ACCIDENTAL RELEASE MEASURES
Small Spill Absorb with an inert solid and scoop up for disposal, then
rinse soiled area with water down the drain.
Large Spill Stop leak at the source and collect into a suitable
container, then treat as a small spill.
SECTION - 7 HANDLING AND STORAGE
Handling Containers of this material may be hazardous when emptied.
Since emptied containers retain product residues (vapor, liquid, and/or
solid), all hazard precautions given in the data sheet must be
observed.
Storage Store in a cool, dry place. Keep container closed when not in
use.
SECTION - 8 EXPOSURE CONTROLS / PERSONAL
PROTECTION
Eye Protection Chemical Splash goggle in compliance with OSHA
regulations are advised: however , OSHA regulations also permit other
type safety glasses. Consult your safety representative.