Pro-Link Phos Clean Restroom Cleaner B14161 - Manual

BIJ MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 7/09 Revision: 3/12
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Big John
Generic Name: Heavy Duty Clinging Bowl, Tile,
& Porcelain Cleaner
Chemical Family: Acid Detergent Blend
Formula: Proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Phosphoric Acid 7664-38-2 20 to 25 1mg/M 3 1mg/M 3 3mg/M 3
Nonionic Surfactant 9016-45-9 0 to 5
Dimethyl Benzyl Ammonium Chloride 8001-54-5 0 to 5
Xanthan Gum 11138-66-2 0 to 5
Perfume Oil N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 210 F. Specific Gravity: 1.139
Vapor Pressure: <20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 65+ pH: 1.0-1.5
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thick pink liquid with pleasant odor.
Flash Point (Method Used): None
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: N/A
Special Firefighting Procedures: Non Flammable
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Phosphoric oxide vapors in a fire. Incompatibility (Materials to Avoid): Strong alkalis.
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER. Corrosive to eyes. Severe skin irritant. Avoid contact with eyes, skin and clothing. Keep out of reach of children. For use by trained personnel only. Keep
container closed during storage. For institutional and industrial use only. Wear rubber gloves and protective eyewear when using. Avoid breathing of vapors. Use in
well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Severe skin irritant. Prolonged or repeated contact can cause chemical burns
or dermatitis.
Eyes: Severe eye irritant. Liquid and mists may burn or injure eyes, causing corneal
damage.
Inhalation: May be irritating to mucous membranes of the nose, throat, and lungs.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache,
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
Respiratory Protection: Use in well-ventilated area.
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2
ingredients below acceptable limit.
Protective Gloves: Acid proof rubber or neoprene.
Eye Protection: chemical splash goggles.
Other Protective Equipment: Eyewash should be available nearby.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush exposed area with large quantities of water. Seek medical attention if
irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention if irritation persists.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. Consult local
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid Identification System
No - Sudden Release of Pressure Hazard (phosphoric acid), 8, NA-1760, PGIII Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: Cleaning Compound LQ Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
REVISION: 3/16/12- Revised Sec. 10 Shipping Information
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Phos Clean