Pro-Link Grout Protector B14171 - Manual

IPG MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 1/09 Revision: n/a
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Impregnator H2O
Generic Name: Water and Oil Stain Repellent
Chemical Family: Fluorochemical Dispersions
Formula: Proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 70 to 100
Aqueous Fluorochemical Solution Trade Secret 0 to 10
Fluoropolymer Dispersion Trade Secret 0 to 10
2-Butoxyethanol 111-76-2 0 to 5
Isopropanol 67-63-0 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 212° F. Specific Gravity: 0.95 – 1.05
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 90+ pH: 8.0 – 9.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin clear light amber liquid with mild characteristic odor.
VOC Content (Subpart D §59.406) : <75 gm/liter
Flash Point (Method Used): 144° F. (TCC)
Upper Explosion Limit: 6.0 Lower Explosion Limit: 1.0
Extinguishing Media: Water mist, Foam, CO
2
, or Dry Chemical
Special Firefighting Procedures: None
Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Will not occur Incompatibility (Materials to Avoid): None
SECTION 6-STORAGE AND HANDLING INFORMATION
Eye and Skin irritant. Avoid contact with eyes, skin and clothing. Avoid breathing of mists. Avoid circumstances that produce respirable particles (fine spray mists). Use in well-
ventilated area only. Wash hands thoroughly after use. Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when applying to floor.
Keep container closed during storage. For institutional and industrial use only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Prolonged or repeated contact may cause moderate irritation including dermatitis.
Eyes: Eye irritant. May cause redness, tearing, burning sensation.
Inhalation: Vapors may be irritating to nose, throat, and lungs. May cause dizziness,
headache, and nausea. Excessive breathing of mists may cause serious injury to lungs.
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system. Vomiting
and diarrhea expected with large doses.
Respiratory Protection: Organic vapor canister respirator when in confined areas.
Ventilation Requirements: Provide adequate local where danger of mist contact will
occur.
Protective Gloves: Chemical resistant rubber.
Eye Protection: Chemical splash goggles where danger of mist contact.
Other Protective Equipment: Eyewash should be available. Protective footwear (e.g.
rubber boots) and protective pants when applying to floors.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention.
Inhalation: Immediately remove victim to fresh air and monitor. Seek medical attention
if signs of irritation or difficulty breathing is observed.
Ingestion: Do not induce vomiting. Dilute with 2 glasses of water. Seek medical
attention if symptoms persist.
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Best method is to recycle or reuse for intended purpose. Consult local authorities for
disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground.
Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Domestic Shipping Information: HMIS Hazardous Materials
Yes - Fire Hazard FOR CONTAINERS > 1 Gallon : Not Regulated Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Not Regulated Flammability 1
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Not Regulated Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Grout Protector