Taylor-Wharton XT Series User Manual
Page 2
pour out the liquid, disposing of it out-of-doors where the
cold liquid will not damage driveways and other surfaces.
Warm the container by purging it with air even after the
container has warmed to room temperature to evaporate
any collected moisture. When the container is ice-free and
dry, rinse the inner vessel with household bleach. Wash
the inner vessel with a 40 to 1 ratio of water to laundry
detergent solution. Rinse and dry inside and out thor-
oughly before placing the container back into service. Do
not use sharp instruments to chip ice; permanent damage
to the container could result. DO NOT attempt to fasten
any device to the container. Welding, brazing, or piercing
of the container in any manner will cause permanent
damage.
Refrigeration depends on the presence of liquid nitrogen in
the refrigerator. Be sure to maintain correct refrigerant
levels to prevent loss of stored material. Check liquid
levels regularly. If high evaporation rates are apparent
under normal operating conditions, the refrigerator may be
losing its vacuum. Sweating and the formation of frost on
the outer casing are indications that the vacuum integrity of
the refrigerator is not normal. All necessary steps should
be taken to protect the refrigerator’s contents. If these
conditions persist, contact your supplier or Taylor-
Wharton’s Technical Response Department at 1-800-TW-
TANKS (989-2657) or email us at
for information on how to
conduct a normal evaporation rate (NER) test in the field.
TRANSPORTAION
Although these refrigerators are rugged, they can be
damaged if abuse or otherwise mishandled. When
moving or transporting the refrigerator, take every precau-
tion to prevent sliding, tipping, bumping, or dropping the
unit. All refrigerators must be kept upright. Refrigera-
tors containing liquid nitrogen must never be transported in
sealed compartments. Ventilation must be assured to
prevent the displacement of air and the related suffocation
hazard.
RETURNS
Manufacturing defects are covered under the containers
limited warranty. Evidence of mishandling, such as dents
on the outer vessel or misalignment of the inner vessel are
not manufacturing defects. If you would like to return
goods to Taylor-Wharton for any reason, you must first
obtain a Material Return Authorization (MRA) number for
tracking purposes. Please have a description of your
symptoms and the refrigerator’s serial number ready.
Contact your supplier or call Taylor-Wharton’s Technical
Response Department at 1-800-TW-TANKS (898-2657) or
email us at
.
ACCESSORIES
The following accessories are available for HC Series
refrigerators:
•
Roller Base – with ball bearing swivel casters to
provide convenience and portability within a working
area where frequent container movement is necessary
or desirable.
P/N – R018-8C00.........XTL8, XT20
P/N – R033-8C00...........XT34
•
Liquid Level Measuring Rod – is graduated in both
inches and centimeters. This accessory is inserted
into the cryogenic refrigerant in order to determine the
actual liquid level.
P/M – R033-8C11.........all units
•
Low Level Alarm – for passive monitoring of refriger-
ant level. This alarm is available for units that may be
used for long-term storage, where an unusually low
liquid level could go unnoticed.
P/N – R033-8C15.........for XT20 and XT34
COMMON PARTS
Lid (XTL8 XT20, XT34) ............................. R033-9C11
Lid Hinge Pin (2 required) .......................... 6550-1000
Lid Hinge Pin Retainer ............................... 8956-1013
Handle (XTL3).............................................R005-5C11
Handle (XTl8, XT10) .................................. R014-5C11
Handle Pin (XTL3, XTL5, XT10) ................ 8632-5000
Taylor-Wharton
4075 Hamilton Blvd.
Theodore, AL 36582
Phone: (251) 443-8680
Fax: (251) 443-2250
(800) TW TANKS (898-2657)
Email: [email protected]
www.taylorwharton.com
7950-8345
TW-345
ORDERING INFRMATION
Order all replacement parts and accessories from your local distributor. Please include the part and model number, quantity,
and each part requested. For more information or the name of your local distributor, contact Taylor-Wharton at the address
listed below.
REPLACEMENT PARTS
Refrigerators
XTL3
XTL8
XT10
XT20
XT34
Canister, Single 5.0 in.
(127 mm)
R003-9C24
R008-9C24
R013-9C23 R010-9C24
R010-9C24
Canister, Single 11.0 in.
(279 mm)
N/A
N/A
R013-9C14 R033-9C24
R033-9C24
Necktube Core
R003-9C16
R033-9C16
R013-9C16 R033-9C16
R033-9C16