Great Plains 10 Gallon Stainless Tank Foam Marker Operator Manual User Manual
Page 2
Table of Contents
©
Copyright 1998 All rights Reserved
Great Plains Manufacturing, Inc. provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the
preparation of this manual, Great Plains Manufacturing, Inc. assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from
the use of the information contained herein. Great Plains Manufacturing, Inc. reserves the right to revise and improve its products as it sees fit. This publication describes
the state of this product at the time of its publication, and may not reflect the product in the future.
Great Plains Manufacturing, Incorporated Trademarks
The following are trademarks of Great Plains Mfg., Inc.: Application Systems, Ausherman, Land Pride, Great Plains
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
500-033M-A
4/21/2003
Important Safety Information . . . . . . . . . . . . . . . . . 1
Wear Protective Equipment . . . . . . . . . . . . . . . . 5
Handle Chemicals Properly . . . . . . . . . . . . . . . . 6
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Intended Usage . . . . . . . . . . . . . . . . . . . . . . 9
Models Covered . . . . . . . . . . . . . . . . . . . . . . 9
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . 9
Definitions. . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . 9
Preparation and Setup . . . . . . . . . . . . . . . . . . . . . 10
200/300 Gallon 3-Point Mounted Sprayer / Foam .
Marker Assembly Instructions and Set-Up . . . . 12
Tractor Requirements . . . . . . . . . . . . . . . . . . . . 13
Operating Instructions . . . . . . . . . . . . . . . . . . . . . 14
Basic Foam Marker Operating Procedures . . . . 14
Filling Foam Tank . . . . . . . . . . . . . . . . . . . . 14
Operating the Foam Control Valve . . . . . . . 14
Operating Checklist. . . . . . . . . . . . . . . . . . . . . . 14
Adjustments. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Field Adjustments . . . . . . . . . . . . . . . . . . . . . . . 15
Foam Marker . . . . . . . . . . . . . . . . . . . . . . . 15
Foam Marker Preparation . . . . . . . . . . . . . . . . . 15
General Notes for Field Operation . . . . . . . 15
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Appendix . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Torque Values Chart . . . . . . . . . . . . . . . . . . . . . 17
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18