Purus Living 600 - Drop/Twist Grate - Manual (Page 10)

10
PURUSLINE LIVING WETROOM SOLUTION Concrete
Important
Read all the pages of these instructions fully and thoroughly before
you commence installing and keep in a safe location for future refer-
ence.
Plumbing
All plumbing work should be carried out by a fully qualified profes-
sional plumber. 1½ inch ABS pipe adapter/connector provided.
CHECK LIST/SAFETY NOTES
• Ensure you have all the contents supplied before installation. If you
do not have all the contents do not install. Contact your distributor
straight away.
• Check all the contents for damage. If any parts are damaged do not
install. Contact your distributor straight away.
• The grate when installed must be horizontal and flat. It also must
be level with the ceramic tile surface and not at an angle or on a
slope.
• Check where all pipes, electrical cables and all other services are
prior to drilling, cutting and screwing into walls, ceilings and floors.
• Ensure your tools for installation are fit for purpose and follow
manufacturer’s instructions provided with the tools.
• Do not use power tools on the screws of the Purusline Living gully.
• Remove any skirting boards in the room.
• Any gaps or holes/damage in the walls and floors must be made
good.
• Always ensure the installation and working areas are kept safe,
especially from children and pets.
• The minimum height of the tile should be 10mm and the maximum
height of the tile should be 26mm including the tile adhesive.
• Work safely; ensure that no tools are lying around and that the
working and installation areas are clean and tidy at all times.
• Ensure that all sharp devices such as knives and saws have covers
on them at all times. Do not carry knives in pockets.
• Safety goggles, masks and gloves should be worn at all times.
• When installing into concrete build falls to the gully with screed so
water can run into it. A 2% fall should be used.
• Concrete floors should be primed with Puragum Primer.
• The tanking kit covers 7-8m².
• Check the litres per minute output of your shower/showers before
choosing the waste outlet especially if you are going to use a pump.
The flow rate for the gully is 60 litres per minute for the Side and Side
Side waste outlets, and 30 litres per minute for the Low waste outlet.
Do not exceed these limits unless using multiple gullies.
Packaging
Once packaging has been unpacked and used it should always be
taken to the nearest local authority waste collection site for recy-
cling. The packaging must not be thrown away with normal house-
hold waste.
Liability
The Manufacturer will not accept any liability for failure if the Purus-
line Living Wetroom Solution has been installed incorrectly and with
disregard to the instructions.
It is extremely important when installing a wetroom that
you fully seal/tank the room.
Take your time. The tanking
of the room is the most important part. Check all tapes
and gaskets are secure and bonded before tiling. Ensure
that you test your room after tiling to ensure the room is
fully watertight. Do not use the wetroom/shower room until
tests are thoroughly completed.
02835