Multiquip WM45HCE_rev_0 - Manual (Page 8)

page 8 — WM45HCe pLaSTeR/MORTaR MIXeR • OpeRaTIOn and paRTS ManuaL — Rev. #0 (02/04/13)
safety infOrMatiOn
MIXeR SaFeTY
dangeR
 neveR operate the equipment in an explosive
atmosphere or near combustible materials. An
explosion or fi re could result causing severe
bodily harm or even death.
 dO nOT mix fl ammable or explosive substances.
WaRnIng
 neveR place your hands inside the drum
while starting or operating this equipment.
 neveR disconnect any emergency
or safety devices. These devices are
intended for operator safety. Disconnection of these
devices can cause severe injury, bodily harm or even
death. Disconnection of any of these devices will void
all warranties.
 Before operating mixer, ensure that safety grate is in
position and correctly fi tted.
CauTIOn
 neveR lubricate components or attempt service on a
running machine.
NOTICE
 aLWaYS keep the machine in proper running condition.
 aLWaYS ensure mixer is on level ground before mixing.
 Fix damage to machine and replace any broken parts
immediately.
 dO nOT tip mixer onto drum mouth when the drum is
rotating.
 Ensure the drum is rotating while fi lling and emptying
the drum.
 aLWaYS store equipment properly when it is not being
used. Equipment should be stored in a clean, dry location
out of the reach of children and unauthorized personnel.
engIne SaFeTY
dangeR
 Engine fuel exhaust gases contain poisonous carbon
monoxide. This gas is colorless and odorless, and can
cause death if inhaled.
 The engine of this equipment requires an adequate
free fl ow of cooling air. neveR operate this equipment
in any enclosed or narrow
area where free fl ow of the
air is restricted. If the air
fl ow is restricted it will cause
injury to people and property
and serious damage to the
equipment or engine.
WaRnIng
 dO nOT place hands or fingers inside engine
compartment when engine is running.
 neveR operate the engine with heat shields or
guards removed.
 Keep fi ngers, hands hair and clothing away
from all moving parts to prevent injury.
 dO nOT remove the engine oil drain plug
while the engine is hot. Hot oil will gush out of the oil
tank and severely scald any persons in the general area
of the mixer.
CauTIOn
 neveR touch the hot exhaust manifold,
muffl er or cylinder. Allow these parts to cool
before servicing equipment.
 Make certain the operator knows how to and is capable
of turning the engine OFF in case of an emergency.
NOTICE
 neveR run engine without an air fi lter or with a dirty air
fi lter. Severe engine damage may occur. Service air fi lter
frequently to prevent engine malfunction.
 neveR tamper with the factory settings
of the engine or engine governor. Damage
to the engine or equipment can result
if operating in speed ranges above the
maximum allowable.
DANGEROUS
GAS FUMES