Multiquip MVH200GH - Manual (Page 15)

MVH-200GH PLATE COMPACTOR — OPERATION & PARTS MANUAL — REV. #2 (09/22/06) — PAGE 15
MVH-200GH — ENGINE COMPONENTS
Figure 4. Engine Controls and Components
The engine shown above is a HONDA GX240K1SMX2 engine
(Figure 4). The engine must be checked for proper lubrication
and filled with fuel prior to operation. Refer to the manufacturers
engine manual for instructions & details of operation and
servicing.
1. Fuel Filler Cap – Remove this cap to add unleaded gasoline
to the fuel tank. Make sure cap is tightened securely. DO NOT
over fill.
6. Choke Lever – Used in the starting of a cold engine, or in
cold weather conditions. The choke enriches the fuel mixture.
7. Air Cleaner – Prevents dirt and other debris from entering
the fuel system. Remove wing-nut on top of air filter cannister
to gain access to filter element.
Operating the engine without
an air filter, with a damaged
air filter, or a filter in need of
replacement will allow dirt to
enter the engine, causing
rapid engine wear.
Adding fuel to the tank should be done only
when the engine is stopped and has had an
opportunity to cool down. In the event of a fuel
spill, DO NOT attempt to start the engine until
the fuel residue has been completely wiped
up, and the area surrounding the engine is dry.
2. Throttle Lever – Used to adjust engine RPM speed (lever
advanced forward SLOW , lever back toward operator FAST ).
3. Engine ON/OFF Switch – ON position permits engine
starting, OFF position stops engine operations.
4. Recoil Starter (pull rope) – Manual-starting method. Pull
the starter grip until resistance is felt, then pull briskly and
smoothly.
5. Fuel Valve Lever – OPEN to let fuel flow, CLOSE to stop the
flow of fuel.
NOTE
CAUTION - Fueling The Engine
8. Spark Plug – Provides spark to the ignition system. Set spark
plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) Clean spark
plug once a week.
9. Muffler – Used to reduce noise and emissions.
Engine components can generate extreme heat.
To prevent burns, DO NOT touch these areas
while the engine is running or immediately after
operating. NEVER operate the engine with the
muffler removed.
CAUTION - Burn Hazard
10. Fuel Tank – Holds unleaded gasoline. For additional
information refer to engine owner's manual.