JLG 45ic Parts Manual - Manual (Page 43)

3120853 1-37
S
E
C
T
I
O
N
1
F
R
A
M
E
SECTION 1 FRAME
87 1320040 Clamp 1
88 0701015 Bolt, Metric M8 x 35mm 8
89 0701014 Bolt, Metric M10 x 30mm 4
90 0641820 Bolt 1/2"-13NC x 2 1/2" 2
91 4751800 Flatwasher 1/2" 2
92 0940070 Bumper, Rubber 2
93 4751000 Flatwasher #10 8
94 4791600 Starwasher 3/8" 2
95 4060807 Flex-Trim (Not Shown - Located on Frame) 15in/38cm
96 4060918 Flex-Trim (Not Shown - Located on Frame) 15in/38cm
97 3311501 Nut 5/16"-18NC 2
98 1320239 Clamp, Loop (S/N 33269 to Present Only) 1
99 0902383 Bracket, Recovery Tank (S/N 33269 to Present Only) 1
100 4420008 Tape, Neoprene (S/N 33269 to Present Only) 7in/18cm
101 2420047 Service Indicator Kit (S/N 33269 to Present Only) 1
102 2220063 Fitting, 90° 1
103 0257589 Timer Module, Assy (See Section 7 For Breakdown) 1
104 3960389 Seal (S/N 33820 to Present Only) 1.42ft/0.44m
105 3960433 Seal (S/N 33820 to Present Only) 1.54ft/0.47m
106 3960477 Seal, Foam Gasket (S/N 33820 to Present Only) 1
107 0181932 Angle (Not Shown) 1
108 1320241 Clamp (Not Shown) 1
2000145 ENGINES COMPONENTS Ref. B
201 7018100 V-Belt 1
202 7018101 Cap, Oil Fill 1
203 7018102 Gasket, Valve Cover (Not Shown) 1
204 7018103 Filter, Oil 1
205 7018104 Dipstick, Engine Oil Level 1
206 7018105 Pump, Water 1
207 7018106 Gasket, Thermostat (Not Shown) 1
208 7018107 Thermostat 1
209 7018108 Switch, Water Temperature 1
210 7018111 Element, Fuel Filter 1
211 7018112 Starter 1
212 7018113 Alternator - 40 Amp 1
213 7018116 Solenoid, ETR Stop (Not Shown) 1
214 7018117 Pump, Injector 1
215 7018118 Pump, Fuel 1
7018119 Lever, 1
216 7018145 Switch, Oil Pressure 1
217 7018146 Fuel Strainer Assembly 1
218 7018147 Plug, Glow (Not Shown) 3
219 7018144 Gasket, Muffler 1
220 7018119 Lever, Regulator (Not Shown) 1
FIGURE 1-10. YANMAR DIESEL ENGINE INSTALLATION. (CONTINUED)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.