JLG 800A_AJ ANSI Parts Manual User Manual
Page 123
2-77
SECTION 2 TURNTABLE
316
70002307
1
Gasket, Exhaust (Manifold to Pipe) (was p/n 7040050)
7022143
1
Gasket, Exhaust (Manifold to Cylinder Head) (Not Shown)
317
7022158
3
Connector
318
7022159
2
Connector
319
7022160
1
Connector
320
7022161
2
Tube, Supply
321
7022162
2
Clamp
322
7022178
1
Sensor, Crank
323
7022149
1
Gasket Kit, Lower Manifold (Not Shown)
7025124
1
Gasket Kit, Upper Manifold (was p/n 7022148) (Not Shown)
7022144
1
Gasket, Upper Manifold Throttle (Not Shown)
324
7023657
1
Harness, TPS Harness (Not Shown)
325
3
Relay Options:
7023613
SN 0300069000 to SN 0300073348 (2000174 Engines)
7023695
SN 0300073348 to SN 0300077500 (2000193 Engines)
326
7022153
1
Pump, Water
7022154
1
Gasket, Water Pump
7022155
1
Sensor, Water Temperature (Not Shown)
7022156
1
Thermostat (Not Shown)
7023644
1
Hose, Water Pump (By-Pass) (Not Shown)
327
2720341
1
Horn, Rubber Air
328
1600363
1
Module, EPM (SN 0300073348 to SN 0300077500) (was p/n
7023684)
1
EPM Update Kit Options:
Ref
Note: Contact JLG Service Dept to determine which kit is
required.
2915195
EPM Update Kit (was p/n 7023685)
2915196
EPM Update Kit (was p/n 7023686)
329
7027402
1
Belt, Drive (was p/n 7019979)
330
7019925
1
PCV Valve (Not Shown)
331
7019930
1
Coil, Ignition (Not Shown)
7022157
1
Wire Set, Spark Plug (Not Shown)
7019932
4
Spark Plug (Not Shown)
332
7022151
1
Cap, Oil Fill
333
70002567
1
Tensioner, Belt
334
7022150
1
Belt, Timing
— — — — — — — — — —
3124114
1
Service Manual, Ford EFI System Diagnostic
0272816
Ref
ENGINE FUEL PUMP ASSEMBLY
A
401
0641405
2
Bolt 1/4in-20NC x 5/8in
402
0641606
4
Bolt 3/8in-16NC x 3/4in
403
1320022
1
Clamp, Hose
404
2720058
4in/10cm
Hose 5/16in
405
2720472
1
Hose, High Pressure
406
2820018
AR
Tubing, Heat Shrink
407
3311401
2
Nut 1/4in-20NC
408
3311605
4
Locknut 3/8in-16NC
FIGURE 2-13. FORD ENGINE INSTALLATION - UL MACHINES (SN 0300069000 TO SN
0300077500) (CONTINUED)
ITEM #
PART NUMBER
QTY.
DESCRIPTION
REV.