JLG 660SJ Service Manual - Manual (Page 18)

SECTION 1 - SPECIFICATIONS
1-2 – JLG Lift – 3121298
1.3 CAPACITIES
1.4 TIRES
1.5 ENGINE DATA
Table 1-3. Capacities
Fuel Tank 40 Gallons (151 L)
Hydraulic Oil Tank 32 Gallons (98.4 L)
Hydraulic System (Including Tank) 40 Gallons (121 L)
Torque Hub, Drive
* 17 ounces (0.5 L)
Engine Crankcase

Deutz D2011L04

GM

11 quarts (10.5 L)

4.5 qts. (4.25 L) w/Filter
*Fill torque hubs half (1/2) full of lubricant.
Table 1-4. Tire Specifications
Size 39 x 15-22.5
Load Range G
Ply Rating 14
Foam Fill (Optional) Foam/Crumb
Diameter 38.5
Width 15.5
Rim Size 11.75 x 22.5
Tire & Wheel Weight 128T, 262FF,
Max Tire Load 16,000 lb (7257 kg) @ 95 psi (6.5 bar)
Size 15 x 19.5 Non-Marking
Load Range G
Ply Rating 14
Foam Fill Foam/Crumb
Diameter 40
Width 15.3
Rim Size 11.75 x 19.5
Tire & Wheel Weight 585 lb
Max Tire Load 20,000 lb @ 95 psi (6.5 bar)
Size 41/18LL x 22.5 Turf/Sand
Load Range H
Ply Rating 16
Foam Fill Soft
Diameter 41
Width 18.4
Rim Size 14 x 22.5
Tire & Wheel Weight 724 lb (329 kg)
Max Tire Load 15,500 lb @ 70 psi/5 bar
Table 1-5. Deutz TD 2.9 Specifications
Fuel Ultra Low Sulfur Diesel (15 ppm)
Output 67 hp (50 kW)
Torque 173 ft.lbs. (234 Nm) @ 1800rpm
Oil Capacity (Crankcase) 2.4 gal (8.9 L) w/Filter
Cooling System 3.3 gal (12.5 L)
Low RPM 1200 ±50 rpm
High RPM 2600±50 rpm
Alternator 95 Amp
Fuel Consumption 0.65 GPH (2.48 lph)
Table 1-6. Deutz D2011L04
Fuel Diesel
Oil Capacity

Cooling System

Crankcase

Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2500
Alternator 60 Amp, belt drive
Battery 950 Cold Cranking Amps, 205
Minutes Reserve Capacity, 12
VDC
Fuel Consumption 0.65 GPH (2.46 lph)
Horsepower 49
Table 1-7. GM 3.0L
Fuel Gasoline or Gasoline/LP Gas
No. of Cylinders 4
BHP

Gasoline

LP
83 hp @ 3000 rpm
75 hp @ 3000 rpm
Bore 4.0 in. (101.6 mm)
Stroke 3.6 in. (91.44 mm)
Displacement 181 cu.in. (3.0 L, 2966 cc)
Oil Capacity w/filter 4.5 qts. (4.25 L)
Minimum Oil Pressure

at idle

Hot
6 psi (0.4 Bar) @ 1000 rpm
18 psi (1.2 Bar) @ 2000 rpm
Compression Ratio 9.2:1
Firing Order 1-3-4-2
Max. RPM 2800
Fuel Consumption N/A