A.J. Antunes & Co ES-1200 9300588 - Manual (Page 15)

egg station
15 P/N 1011004 Rev. B 08/08
1 0021327 Nose Piece Weldment 1
3 7000674 Grill Platen 1
4 040P138* Lock-nut, Conduit - 1/2” NPT 1
5 0400315 Strain Relief - Cord Connector 1
7 2180259 Scrap Pan 2
11 0502900 Bracket, Sensor 1
12 7000675 Cover, Rack, & Ring Assembly 1
(Incl. All Shown)
13 7000676 Cover, 12 Egg 1
(Incl. #28, 48, 65, 74, 75, & 76)
14 7000677 Rack, 12 Egg Ring 1
(Incl. #27, 45, 75, 76, & 78)
15 0021399 Panel, Base 1
16 0021325 Housing, Main 1
18 0504075 Cover, Insulation 2
19 0021326 Rear Panel Weldment 1
21 0504078 Bracket, Hi-Limit 1
24 0700453 CEE 7/7, 16 Amp., 250 VAC 1
25 1001100 Label, Control 1
26 210K122 Adj. Leg Kit (4 Pack) 1
27 2100137 Knob Ball 1
28 2100138 Knob Ball 1
29 210K108 Rubber Tip Kit (4 Pack) 1
31 2130111 Egg Ring (Single) 12/6
213K101 Egg Ring (Pack of 6) 1/2
33 300P102* Nut, Speed #8-32 “U” 1
37 306P113* Screw, Mach. 2
#6-32 x 5/8” Sltrshd
38 306P123* Screw, Mach. 4
#6-32 x 7/8” Sltrshd 2
39 306P130* Nut, Hex KEPS #6-32 6
40 308P102* Washer, Int. Tooth #8 1
41 308P104* Screw, Mach #8-32 x 3/8” Sltrshd 1
42 308P143* Nut, Hex KEPS #8-32 1
43 308P157* Screw, Tap #8-32 x 3/8” 1
44 310P102* Washer, Int Tooth-lock #10 2
45 310P109* Screw, Mach 1
#10-32 x 3/8” Sltrshd
46 310P136* Screw, Mach. 1
#10-32 x 1 and 1/4” Slpanhd
47 310P149* Screw, Mach. 1
#10-32 x 7/8” Slpanhd 1
48 325P101 Stud 1/4-20 x 1-1/2” 1
49 325P104* Washer, Flat 1/4” S/S 1
50 325P109* Screw, Hxcap 1/4-20 x 3/4” 1
51 4010137 Switch, Rocker (25A-250V) 1
52 4010187 Transformer, Stepdown 1
(240V/12)
53 4010190 Switch, Momentary 1
54 4010193 PC-Board, Switch-Two Button 1
55 7000272 Thermostat, Hi-Limit 1
56 4050229 Line Filter (Mfg. # 9300587 only) 1
57 7000370 Solid State Relay 1
58 7000136 Terminal Block, 3-Pole 1
59 4060362 LED, Snap-in (Green - Ready) 1
60 4060363 LED, Snap-in (Yellow - Cooking) 1
61 4060385 LED, Snap-in (Blue - Bacon) 1
62 7000520 Control Board 1
63 7000391 A/C Line Isolator Board 1
64 0400337 Insulation 1
65 2120111 Spacer 1
66 4050214 Thermocouple 1
67 2180111 Plastic Dispensing Bottle 1
(not shown)
68 213K115 Spatula, Scraper and Brush Kit 1
(not shown)
69 0011251 Heat Sink Assembly 1
70 0700648 Wire Set, Main (not shown) 1
71 0700655 Wire Harness/PCB-LEDs 1
(not shown)
72 0700656 Wire Harness/PCB-Isoloator BD 1
(not shown)
73 0700657 Wire Harness/PCB-2 Button Bd 1
(not shown)
74 0021396 Cover Handle Weldment 1
75 3060103 Screw Mach #6-32 x 3/8” 4
Sltrshd 304 S/S Brt.
76 3060152 Nut, Acorn #6-32 4
Low Crown w/ centerlock
78 0504562 Handle, Rack 1
79 2120180 Spacer .312 oD x .257 ID 6
x .13 LG S/S
80 3250132 Screw, Mach 1/4-20 x 1/2” 6
* Available only packages of 10.
Item Part Description Qty.
no.
Item Part Description Qty.
no.
RePlaceMenT PaRTs (continued)