Banks Power Ford Motorhomes: (Gas ’05 - 14 6.8L V-10, Class-A (30-valve) Power Systems- PowerPack, Stinger & TorqueTube systems, (Class-A) '05-12 User Manual
Page 15
96377 v.7.0
15
5.
DRYING HINTS
Always dry naturally. After rinsing,
shake off all excess water and let the
element dry naturally. Do not USe
coMPReSSeD AIR – Do not USe oPen
FLAMe – Do not USe HeAt DRYeRS!
eXceSS HeAt WILL SHRInK tHe
cotton FILteR MeDIA. coMPReSSeD
AIR WILL BLoW HoLeS In tHe
eLeMent.
6.
AEROSOL OILING
After cleaning air filter always reoil
before using. Spray Banks Ram-Air
filter oil down into each pleat with one
pass per pleat. Wait 10 minutes and
re-oil any white spots still showing.
7.
OILING HINTS
never use a Banks Ram-Air filter
without oil (the filter will not stop the
dirt without the oil). Use only Banks
Ram-Air filter oil. Banks air-filter oil is
a compound of mineral and animal oil
blended with special polymers to form
a very efficient tack barrier. Red dye
is added to show just where you have
applied the oil. Eventually the red color
will fade but the oil will remain and
filter the air. NEVER USE Automatic
Transmission Fluid. NEVER USE Motor
Oil. NEVER USE Diesel Fuel. NEVER USE
WD40, LPS, or other light-weight oils.
8.
REINSTALL
Reinstall your Banks Ram-Air filter
element with proper care. Make sure
the element seats properly in the filter
case. Install the cover making sure it’s
in the right position. Tighten all the
nuts, bolts, screws or clips to factory
specifications.
9.
DO NOT DISCARD
Affix the “Do Not Discard” sticker to
the filter case (included with every
Banks replacement element). Make
sure you put the sticker in a highly
visible place to alert your mechanic
not to discard.
10.
PERFORMANCE HINTS
Service every 50-100,000 miles on
street-driven applications. Service
more often in offroad or heavy-dust
conditions. If an air-filter restriction
gauge is installed, then change the
element when the air-filter restriction
reaches 18”–H
2
o.
CAUTION! Extremely fine dust from
agriculture or offroad use will pull
the oil from the element. Frequent
reoiling of the element’s clean side
might be required. Completely
service when practicable. For extra
protection use an air-filter sealing
grease on rubber ends of the
element. Service only with Banks
air-filter cleaner and Banks air-filter
oil.
-enD, SectIon 4-