Raypak XTHERM 1505 - Manual (Page 8)

HEA
T
EXCHANGER
JACKET
OTHER
G
A
S
TR
A
IN
SAFETIES
OPERA
TING
CONTROLS
ASME, National Board Registered, 160 PSI • HLW Stamp ⅷ N/A
• H Stamp N/A ⅷ
Heat Exchanger Tubes • Copper ⅷ ⅷ
• Cupro Nickel ⅜ ⅜
Bronze Headers ⅷ ⅜
Cast Iron Headers N/A ⅷ
Stainless Steel Condensing Heat Exchanger • U Stamp ⅷ ⅷ
Pressure Relief Valve • 60 PSI ⅜ ⅷ
(mounted on outlet) • 125 PSI ⅷ ⅜
• 30, 45, 75, 150 PSI ⅜ ⅜
Temperature & Pressure Gauge ⅷ ⅷ
Pump • 120V, Single-Phase ⅷ ⅷ
Indoor/Outdoor Certified ⅷ ⅷ
Vent Terminal • Outdoor ⅜ ⅜
• Through-the-Wall ⅜ ⅜
Fully-Enclosed Controls ⅷ ⅷ
Combustible Floor Rated ⅷ ⅷ
120V Power Supply with 120V/24V Transformer ⅷ ⅷ
On/Off Switch ⅷ ⅷ
Programmable Pump Time Delay, Single-Phase • Included in TempTracker Mod Controller ⅷ ⅷ
Terminal Block Connections • Enable / Disable ⅷ ⅷ
(Front mounted) • External Interlocks ⅷ ⅷ
• 0-10 VDC Setpoint/Direct Drive Input dry contacts ⅷ ⅷ
LCD diagnostic display with 16-Event History (2x20 character display, reads in plain English) ⅷ ⅷ
Status Display Lights (4) ⅷ ⅷ
Temperature Controller with 3 Water Sensors • TempTracker Mod (up to 4:1 Turndown) ⅷ ⅷ
• Outdoor Reset Sensor N/A ⅜
Multiple Boiler Controller • TempTracker Mod+, up to 16 boilers ⅜ ⅜
Hot Surface Ignition System • 1-try ⅜ ⅜
• 3-try ⅷ ⅷ
High/Low Gas Pressure Switches ⅜ ⅜
Blocked Vent and Air Pressure Switches ⅷ ⅷ
High Limit Switch • Manual Reset, Fixed ⅷ ⅷ
• Manual Reset, Adjustable ⅜ ⅜
• Automatic Reset, Adjustable ⅜ ⅜
Low Water Cut-Off, 24V • With Manual Reset and Test Buttons ⅜ ⅜
Flow Switch ⅷ ⅷ
Modulating Combination Gas Valve ⅷ ⅷ
Combustion Air Blower ⅷ ⅷ
Additional Safety Valve • Motorized (externally mounted) ⅜ ⅜
• Solenoid (externally mounted) ⅜ ⅜
CSA-Certified Efficiency • 96% at Full Fire N/A ⅷ
• 97% at Full Fire ⅷ N/A
Air Filter ⅷ ⅷ
TruSeal Direct-Vent Ready ⅷ ⅷ
Alarm System ⅜ ⅜
CSD-1 / GE GAP Control System ⅜ ⅜
Low NOx • Meets all current requirements ⅷ ⅷ
Cold Water Run • Prevents condensation in primary heat exchanger ⅷ ⅷ
Water Heaters
(Type WH)
Boilers
(Type H)
ⅷ ⅷ = Standard ⅜ ⅜ = Optional
Raypak, Inc. • 2151 Eastman Avenue, Oxnard, CA 93030 • phone: (805) 278-5300 • fax: (800) 872-8725 • www.raypak.com
Cat. No. 1000.21C Effective 01-15-11 Replaces 10-01-10
ULTRA HIGH EFFICIENCY
®