Raypak XFYRE NINETY PLUS 500 - Manual (Page 8)

HEA
T EXCHANGER
JACKET
OTHER
GAS TRAIN
SAFETIES
OPERA
TING CONTROLS
ASME Section IV, National Board Registered, 160 PSI • H Stamp ⅷ ⅷ
Heat Exchanger Tubes • 316L Stainless Steel ⅷ ⅷ
Stainless Steel • CSA Verified AB-1953 CA low lead compliant ⅷ ⅷ
Pressure Relief Valve • 60 PSI ⅜ ⅷ
(loose) • 125 PSI ⅷ ⅜
• 30, 45, 75, 150 PSI ⅜ ⅜
Temperature & Pressure Gauge (Loose) ⅷ ⅷ
Pump • 120V, Single-Phase ⅜ ⅜
Indoor/Outdoor Certified ⅷ ⅷ
Vent Terminal • Outdoor ⅜ ⅜
• Through-the-Wall ⅜ ⅜
Fully-Enclosed Controls ⅷ ⅷ
Combustible Floor Rated ⅷ ⅷ
120V Power Supply ⅷ ⅷ
On/Off Switch ⅷ ⅷ
Programmable Pump Time Delay, Single-Phase • Included in Controller ⅷ ⅷ
Terminal Block Connections • Enable / Disable ⅷ ⅷ
(Front mounted) • 0-10 VDC Setpoint/Direct Drive Input ⅷ ⅷ
LCD diagnostic display with 10-Event History (2x20 character display, reads in plain English) ⅷ ⅷ
Temperature Controller with 3 Water Sensors • (up to 5:1 Turndown) ⅷ ⅷ
• Outdoor Reset Sensor N/A ⅜
Multiple Boiler Controller • TempTracker Mod+ Hybrid, up to 16 boilers ⅜ ⅜
Direct Spark Ignition System • 1-try ⅜ ⅜
• 4-try ⅷ ⅷ
High/Low Gas Pressure Switches ⅜ ⅜
Blocked Vent and Air Pressure Switches ⅷ ⅷ
High Limit Switch • Manual Reset, Fixed ⅷ ⅷ
• Automatic Reset, Fixed ⅷ ⅷ
Low Water Cut-Off, 24V • With Manual Reset and Test Buttons ⅜ ⅜
Flow Switch ⅷ ⅷ
Modulating Combination Gas Valve ⅷ ⅷ
Combustion Air Blower ⅷ ⅷ
Additional Safety Valve • Motorized (externally mounted) ⅜ ⅜
• Solenoid (externally mounted) ⅜ ⅜
CSA-Certified Efficiency • 94% at Full Fire ⅷ ⅷ
• 99% at Part Load ⅷ ⅷ
Air Filter ⅷ ⅷ
TruSeal Direct-Vent ⅜ ⅜
Alarm Contacts ⅷ ⅷ
CSD-1 / GE GAP Control System ⅜ ⅜
Low NOx • Meets all current requirements ⅷ ⅷ
Condensate Drain and Trap ⅷ ⅷ
Condensate Neutralizer ⅜ ⅜
Hot Water
Supply Boilers
(Type W)
Boilers
(Type H)
ⅷ ⅷ = Standard ⅜ ⅜ = Optional
Raypak, Inc. • 2151 Eastman Avenue, Oxnard, CA 93030 • phone: (805) 278-5300 • fax: (800) 872-8725 • www.raypak.com
© 2009 Raypak, Inc. Cat. No. 1000.22 Effective: 01-01-10 Replaces: New
TM