McCulloch Woodchuck FB4052 - Manual (Page 2)

3 2
EN SAFETY WARNINGS & INSTRUCTIONS EN
Read and understand the owner's manual and labels affixed to the log splitter. Learn
its application and limitations as well as the specific potential hazards peculiar to it.
• UNDERSTAND YOUR LOG SPLITTER
• DRUGS, ALCOHOL AND MEDICATION
Do not operate the log splitter while under the influence of drugs, alcohol, or any medication that
could affect your ability to use it properly.
• AVOID DANGEROUS CONDITIONS
Put the log splitter on a 60 - 75cm high, stable, flat, and level work bench where there is plenty of
room for handling, and help the operator stay altert. Bolt the log splitter to the work surface if it
tends to slip, walk, or slide.
Keep your work area clean and well lighted. Cluttered areas invites injuries.
Do not use the log splitter in wet or damp areas or expose it to rain.
Do not use it in areas where fumes from paint, solvents or flammable liquids pose a potential haz-
ard.
• INSPECT YOUR LOG SPLITTER
Check your log splitter before turning it on. Keep guards in place and in working
order. Form a habit of checking to see that keys and adjusting wrenches are
removed from tool area before turning it on. Replace damaged, missing or failed
parts before using it.
• DRESS PROPERLY
Do not wear loose clothing, gloves, neckties or jewelry (rings, wrist watches). They
can be caught in moving parts.
Protective electrically non conductive gloves and non-skid footwear are recom-
mended when working. Wear protective hair covering to contain long hair, prevent-
ing it from get caught in machinery.
• PROTECT YOUR EYES AND FACE
Any log splitter may throw foreign objects into the eyes. This can cause permanent
eye damage. Always wear safety goggles. Everyday eyeglasses have only impact
resistant lenses. They are not safety glasses.
Do not put the log splitter on the ground for operations. This is awkward operating
position that the operator has to bring his face close to the machine, and thus risks
being struck by wood chips or debris.
• EXTENSION CORDS
Improper use of extension cords may cause inefficient operation of the log splitter which can result
in overheating. Be sure the extension cord is no longer than 10m and its section is no less than
2.5mm2 to allow sufficient current flow to the motor.
Avoid use of free and inadequately insulated connections. Connections must be made with pro-
tected material suitable for outdoor use.
• AVOID ELECTRICAL SHOCK
Check that the electric circuit is adequately protected and that it corresponds with the power, volt-
age and frequency of the motor. Check that there is a ground connection, and a regulation differ-
ential switch upstream.
Ground the log splitter. Prevent body contact with grounded surfaces: pipes, radiators, ranges, and
refrigerator enclosures.
Never open the pushbutton box on the motor. Should this be necessary, contact a qualified electri-
cian.
Mark sure your fingers do not touch the plug's metal prongs when plugging or unplugging the log
splitter.
The log splitter must be always operated by one person only. Other people
should keep a safe distance from the work area, especially when the log splitter
is under operations. Never use another people to help you with freeing jammed
log.
• KEEP VISITORS AND CHILDREN AWAY
• INSPECT YOUR LOG
Make sure there are no nails or foreign objects in logs to be split. The ends of the logs must be cut
square. Branches must be cut of flush with the trunk.
• DON'T OVERREACH
Floor must not be slippery.
Keep proper footing and balance at all times.
Never stand on log splitter. Serious injury could occur if the tool is tipped or if the cutting tools is
unintentionally contacted. Do not store anything above or near the log splitter where anyone might
stand on the tool to reach them.
Always pay full attention to the movement of the log pusher.
Do not attempt to load the log on until the log pusher has stopped.
Keep hands out of the way of all moving parts.
• AVOID INJURY FROM UNEXPECTED ACCIDENT
Keep you hands away from splits and cracks which open in the log; They may close
suddenly and crush or amputate your hands.
Do not remove jammed logs with you hands.
• PROTECT YOUR HANDS
• DON'T FORCE TOOL
It will do a better and safer job at its design rate. Never try to split logs larger than those indicated
in the specifications table. This could be dangerous and may damage the machine.
Don't use log splitter for a purpose for which it was not intended.
• NEVER LEAVE TOOL RUNNING UNATTENDED
Don't leave tool until it has come to a complete stop.