King Kooker 2292 V Bottom Outdoor Cooker - Manual (Page 16)

1. Never operate this appliance within 10 feet (3.05m) of any structure, combustible material or other gas
cylinder. Never operate this appliance within 25 feet (7.5m) of any flammable liquids or vapors.
2. There must be no combustibles or roof overhead.
3. Keep 24” (.61m) of space between the LP gas cylinder and the appliance.
4. The LP gas cylinder and appliance must be located so that any wind is blowing the heat of the appliance
away from the propane cylinder. This also helps fire prevention by blowing the flames of a grease fire
away from the propane cylinder.
5. ONLY use the pot provided with your appliance.
16
PlAcement InstructIons
Keep twenty-four inches between the
cylinder and the appliance. Placing the
cylinder too close to the appliance could
result in fire or explosion which could cause
property damage, personal injury or death.
the hose connecting the appliance to the
tank poses a trip hazard. do not step over
the hose or walk between the cylinder and
appliance. tripping could cause the appli-
ance or cylinder to tip over, leading to fire or
explosion which could cause
property damage, personal injury or death.
lIGHtInG And oPerAtInG InstructIons
tHe cooKer must not be lIt untIl tHe PrecedInG
PlAcement InstructIons HAVe been comPletely FolloWed.
(ILLUSTRATIONS PAGE 17)
1. For optimum performance it is necessary to adjust the flame quality without the pot installed onto the frame
to more easily view that all of the burner ports are lit. Follow the below instructions without the V-Bottom pot
installed onto the frame to properly prepare the appliance for cooking. neVer put hands or face directly above
burner while lighting or while the appliance is lit. neVer place an empty pot over a lit burner. A hole will be
burned into the bottom of the pot. After following steps #2 through #7 below without the pot installed onto the
cooker frame, you will be directed to follow these lighting steps again, this time with the pot installed and the
cooking liquid added.
2. Check the burner to make sure it is set up as per the illustration (Figure 1).
3. Make certain that the regulator control is turned to OFF by turning it counterclockwise until it reaches the stop.
4. Open cylinder control valve by turning it counterclockwise as per the diagram (Figure 2).
5. To start timer operation, push the black “POWER” button. Both lights will blink once. Press red “START” button.
The green light will remain on. The timer is now set for a 15 minute operational cycle. Gas will not flow to the
burner unless the timer is turned on.
6. Insert a multipurpose lighter through the hole in the side of the cooker body as per Figure 4, or paper book
match through the hole in the side of the cooker body as per Figure 3.
Turn the regulator control toward the “ON” position until ignition occurs. Turning the regulator control clockwise
increases the gas pressure to the burner and hence the flame size (Figure 2).
When lighting the stove, if ignition does not occur in 3 to 5 seconds, turn the regulator and cylinder valve off.
Wait 5 minutes for gas to disperse. Repeat procedure.
7. Check that the flame is blue and that the flames are emitted from every port in the casting (Figure 5). If not,
loosen the air shutter with the aid of a screwdriver and rotate the air shutter position until there is a blue flame.
Tighten. Opening the shutter too much will cause the flame to “Lift” off the burner.
If there is a yellow flame, or if some ports have no flame, this indicates there may be an obstruction in the venturi
tube or ports. Check the maintenance instructions on page 18 for more information regarding a yellow flame.
8. Once the flame quality has been properly adjusted, turn the flame OFF according to the instructions for turning
off gas to the appliance located on pg. 18. Install the pot onto the cooker frame and add cooking liquid to the
fill line. Light the appliance according to lighting directions above (#2 through #6.)
lighting and operation Instructons continued on pg. 17
WInd dIrectIon
cleAr oVerHeAd
10 Feet
to
neArest
combustIble
(All directions)
(3.05m)
Ground leVel
(3.05m)
10 Feet
lP
GAs
tAnK
(.61m)
24 IncHes