Earlex hv5500 - Manual (Page 5)

5
●
CAUTION: TO REDUCE THE RISK OF ELECTRIC SHOCK
OR INJURY, DO NOT EXPOSE TO RAIN, STORE INDOORS.
●
The substances used with this spray applicator (paint, thinners etc)
may contain hazardous, harmful, explosive or corrosive materials.
ALWAYS COMPLY WITH THE SAFETY INSTRUCTIONS ISSUED
WITH THIS PRODUCT AND THE MATERIAL BEING USED.
●
Your Spray Station must only be used with paints and solvents that
have a suitable flash point for spraying. If in doubt, consult the paint
or solvent manufacturer's data.
●
Always ensure there is adequate ventilation when spraying.
●
NEVER spray near an open flame, including an appliance pilot flame.
●
NEVER smoke when spraying.
●
Always disconnect the unit from the power supply when cleaning the
spray applicator.
●
Always ensure the spray area is safe and free from all debris that may
present a fire or trip hazard.
●
NEVER, under any circumstances, point the spray gun at another
person or animal. In the event of injury occurring, seek expert medical
advice immediately.
●
NEVER allow children or unauthorised users to operate or play with
the spray equipment. This equipment is for professional use only.
●
Always read the paint manufacturer's thinning instructions before use.
●
Always wear the correct protective face mask when spraying. We also
recommend wearing gloves, goggles and overalls.
●
After every use ensure that you clean the spray gun thoroughly and
grease the gland washer.
●
Use only genuine manufacturer replacement parts.
●
Only use the spray equipment as detailed in these instructions.
●
Do not use the air hose or power cord to pull the HVLP unit.
●
Check the hose, hose connectors and power cord daily. Any worn or
damaged parts should be replaced immediately.
●
This appliance is recommended for household use only.
●
This appliance is not intended for use by persons (including children)
with reduced physical, sensory or mental capabilities, or lack of
experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person
responsible for their safety.
EXTENSION CORDS
Your Earlex Spray Station is supplied with a power cord that is 6 feet long. Make sure your extension cord is in good condition. When using an
extension cord, be sure to use one heavy enough to carry the current your product will draw. For lengths between 0 feet and 50 feet, 18 AWG
extension cords should be used.
DOUBLE INSULATED APPLIANCE
This is a double insulated appliance and as such, does not require three-way grounding. This product is equipped with a polarized alternating current
line plug (a plug having one blade wider than the other) and does not require a grounding adapter. This plug will fit into the power outlet only one way.
This is a safety feature.
If you are unable to insert the plug fully into the outlet, try reversing the plug. If the plug should still fail to fit, contact a
qualified electrician to replace the obsolete or damaged outlet. Do not defeat the safety purpose of the polarized plug.
MAINS
SWITCH
SHOWN IN
OFF POSI-
TION
SAFETY OPERATING INSTRUCTIONS
WARNING! FIRE AND EXPLOSION HAZARD
IMPORTANT ELECTRICAL INFORMATION
Questions? Call toll free: 888-783-2612
Key Description Part No
1. Air cap ring L0151
2. Air cap L0152
3. Air distributor plate sssy L0162
4. Fluid tip, 0.08” L0157
5. Fluid tip seal L0159
6. Pivot screw L0179
7. Washer L0195
8. Main body assy L0180
9. Fluid needle 0.08” L0166
10. Adaptor L0174
11. Spring L0175
12. Adjusting screw L0176
13. Pivot L0178
14. Air feed tube L0182
15. Gland nut L0173
Key Description Part No
16. Gland washer (2 pcs) L0168
17. Paint container L0190
18. Centre bolt nut L0189
19. Gasket L0188
20. Lid assy L0187
21. Shim L0186
22. Clamp lever L0185
23. Yoke L0184
24. Centre bolt & pick up tube assy L0183
25. Operating lever L0177
26. Viscosity cup SG243
27. Spanner L0191
28. Filter (not shown) L0058
29. Hose 13ft L1107
30. Hose clip L1289
Needles and fluid tips of different sizes can be obtained as sets under the following accessory numbers. Please call our toll free helpline to order these
on 888-783-2612.
0.04”/ 1.0mm dia fluid tip, needle & seal
HV5ACC10USR
0.06”/ 1.5mm dia fluid tip, needle & seal HV5ACC15USR
0.08”/ 2.0mm dia fluid tip, needle & seal HV5ACC20USR
0.10”/ 2.5mm dia fluid tip, needle & seal HV5ACC25USR
OPTIONAL EXTRAS
The following parts are available from Earlex Inc. Please call our toll free helpline: 888-783-2612
PARTS LIST
L1325_5500_0311.qxd:Layout 2 7/3/11 17:00 Page 5