E-Z-GO TERRAIN 1000 - Manual (Page 49)

40
MAINTENANCE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
Owner’s Guide
REAR AXLE
The only maintenance required for the first five years is the periodic inspection of
the rear axle for lubricant leakage. Unless leakage is evident, the lubricant need
only be replaced after five years. Refer to the Service and Repair Manual for the
fluid replacement procedure.
Checking the Lubricant Level
Clean the area around the check/fill plug and remove plug. The correct lubricant
level is just below the bottom of the threaded hole. If lubricant is low, add lubricant
as required. Add lubricant slowly until lubricant starts to seep from the hole. Install
the check/fill plug. In the event that the lubricant is to be replaced, the oil pan must
be removed or the oil siphoned through the check/fill hole.
LUBRICATION
Do not use more than three (3) pumps of grease in any grease
fitting at any one time. Excess grease may cause grease seals
to fail or grease migration into areas that could damage compo-
nents.
Putting more than three pumps of grease in a grease fitting could
damage grease seals and cause premature bearing failure.
CAPACITIES AND REPLACEMENT PARTS
Rear Axle Oil 12 oz (1.2 liters) 30 WT Engine Oil
Fuse 15 amp (P/N 18392-G1)
Headlight Bulb P/N 619100
LED Bulb P/N 619101
Turn Signal Bulb P/N 619102
Taillight Bulb #1157 (P/N 21759-G1)
Hydraulic Brake Fluid DOT 3
Check/Fill Plug
Lubrication Points
View from Underside of Vehicle
Rack Ball Joint