LABEC AA9 - Manual (Page 6)

Maintenance
The cabinet is finished with stainless steel and to maintain appearance should be wiped over with a
non abrasive cleanser. The chamber is manufactured from stainless steel and may be cleaned with
a solvent and if grained stainless steel chamber a stainless steel scratch pad may be used. The
pad should be rubbed in the same direction as the grain pattern of the stainless steel.
The silicone gasket should be cleaned with detergent only, ensuring it is dried completely after
washing. To prolong life it may be stored at cool temperatures in a container of water. Gasket
lubricant is available to provide prolonged life and better sealing on the gasket.
The locking pins should be regularly greased with high temperature grease to reduce binding in the
guides.
WARNING: THIS AUTOCLAVE SHOULD NEVER BE CONNECTED TO MAINS WATER SUPPLY
Troubleshooting
SYMPTOM REMEDY
No Power
(Indicator Light is off)
1. Check autoclave is plugged in and power
switched on.
2. Ensure mains power supply point is
functioning by using a test appliance on
power socket.
3. Check internal RCD has not tripped.
Failure to heat or maintain temperature
(Indicator light is on) 1. The temperature controller is on.
2. The water level is above the low water
sensor and the low water indicating lamp
is off.
The timer does not start 1. Check the AL4 value is equal to set value
as this value activates the timer.
If the fault cannot be found call your distributor or the manufacturer quoting the serial number of the
autoclave from the manufacturers label.
Declaration of Conformity
Each product is thoroughly inspected and tested to not only ensure that it meets the specifications
provided, but to also meet Australian Electrical Standard AS3820 and EMC Standard
AS/NZ1044:1995,and therefore being accredited with a C Tick label. Labec Autoclaves are
constructed in accordance with Australian Standard 1210 and are approved by Workcover Authority
of NSW with reciprocal approval by equivalent bodies in all states of Australia.
Laboratory Equipment Pty Ltd Instruction Manual ­ Autoclave AA9 Bench Top Model