Cub Cadet 7254 - Manual (Page 32)

32
• Because battery acid is corrosive, do not pour it
into any sink or drain. Before discarding an
empty electrolyte container, rinse it thoroughly
with a neutralizing solution.
• NEVER connect (or disconnect) battery charger
clips to the battery while the charger is turned
on, as it can cause sparks.
• Keep all sources of ignition (cigarettes,
matches, lighters) away from the battery. The
hydrogen gas generated during charging can
be combustible.
• As a further precaution, only charge the battery
in a well ventilated area.
• Always shield eyes and protect skin and
clothing when working near batteries.
WARNING: Batteries contain sulfuric
acid and may emit explosive gases.
Use extreme caution when handling
batteries. Keep batteries out of the
reach of children.
BATTERY REMOVAL
WARNING: Battery posts, terminals
and related accessories contain lead
and lead compounds. Wash hands
after handling.
The battery is located at the front of the tractor
beneath the hood, just forward of the radiator.
To remove the battery:
• Open the tractor hood as described in the
previous sub-section.
• Remove the two wing nuts and the battery
holddown strap from the battery holddown rods.
See Figure 37.
• Spread the locking clips on the sides of the
terminal covers and lift the tops of the covers to
expose the battery connections. See Figure 37
• Loosen the cable clamp of the negative battery
lead, then lift the negative cable and its termi-
nal cover off the negative battery post. Move
the cable away from the negative battery post.
• Repeat the above procedure to remove the
cable and cover from the positive battery post.
• Carefully lift the battery out of the tractor.
Install the battery by repeating the above steps in
the reverse order.
WARNING: Always connect the posi-
tive lead to the battery before con-
necting the negative lead.
Figure 37
BATTERY MAINTENANCE
The battery is filled with battery acid and then
sealed at the factory. However, even a
“maintenance free” battery requires some
maintenance to ensure its proper life cycle.
• Spray the terminals and exposed wire with a
battery terminal sealer, or coat the terminals
with a thin coat of grease or petroleum jelly, to
protect against corrosion.
• The battery should be kept clean. Any deposits
of acid should be neutralized with baking soda
and water. Be careful not to get this solution in
the cells.
• Avoid tipping. Even a sealed battery will leak
electrolyte when tipped.
BATTERY STORAGE
• When storing the tractor for extended periods,
disconnect the battery cables. Removing the
battery from the unit is recommended.
• All batteries discharge during storage. Keep the
exterior of the battery clean, especially the top.
A dirty battery will discharge more rapidly.
• The battery must be stored with a full charge.
As the battery discharges, the electrolyte is
weakened and will freeze at a higher
temperature.
• Recharge the battery before returning to service;
or every two months, whichever comes first.
BATTERY
HOLDDOWN
ROD
HOLDDOWN STRAP
WING NUT
CABLE
CLAMP
TERMINAL
COVER