Cub Cadet 641 - Manual (Page 17)

17
• Replace all worn, damaged, or missing parts and
tighten loose hardware as needed.
• Wash the vehicle and clean inside the engine
compartment and under the cargo box.
• Run engine for several minutes to dry belts,
pulleys, and other moving parts.
• Clean and polish metal and plastic surfaces.
• Apply light coat of oil to pivot and wear points to
prevent rust.
• Lubricate grease points.
• Replace fuel filter if needed. See engine manual.
• Change engine oil and filter. See engine manual.
• Drain all old fuel from tank.
Prepare fuel system for storage.
If planning to store vehicle with fuel tank empty:
• Add a small quantity of fresh stabilized fuel to tank.
Run engine until it runs out of fuel. This will circulate
fuel mixture through engine.
If planning to store vehicle with fuel in the tank:
• Fill tank completely with fresh stabilized fuel to
prevent condensation build-up. Run engine for
several minutes to circulate fuel mixture through
engine.
• Turn the ignition key to the STOP position and
remove the key.
• Remove and clean battery. See Battery in Service
Section.
• Store battery in a cool, dry place. Fully charge
battery periodically during storage to maintain its
longevity.
• Support vehicle safely on blocks or stands to take
weight off tires. Reduce 1/3 air from tires.
• Cover vehicle with waterproof cover if stored
outside.
SECTION 5: SERVICE CHART
SECTION 6: ACCESSORIES
NOTE: Some of these accessories may come already
equipped on your vehicle. If they are not equipped, they
may be ordered through your local Cub Cadet service
dealer.
Before
Each
Use
First
10 Hours
Every
50 Hours
Every
100 Hours
Every
500 Hrs
or 2 years
Check Transaxle Oil
Change Transaxle Oil
Tighten Wheel Bolts
Drive Chain Tension
Check Drive Belt
Grease Front Steering Spindle
Grease Axle Shaft U-Joints
Grease Rear & Center Arms
Grease Chain & Rollers
Check Interlock Switch System
Replace Interlock Switch
Description Model Number
Electric Bed Lift 39A-126-100
Horn 39A-101-100
Rear Electric Outlet 39A-102-100
Rear Receiver Hitch 39A-103-100
Brush Guard 39A-104-100
Floor Mat 39A-105-100
Front Receiver Hitch 39A-106-100
Heavy Duty Tires 39A-107-100