Gastroback 46011 Design Pro Vacuum Sealer - Manual (Page 14)

Trouble shooting
possible problem
solution
The appliance does not
generate a vacuum inside
the container
After the sealing process is
finished the plastic bag is
loosing its vacuum
The container is loosing its
vacuum
• Check if:
- the vacuum hose is connected properly to the hose port (How to
vacuum-pack in a container)
- The vacuum bell jar is connected properly to the lid of the container. The
vacuum bell jar has to be hermetically sealed (During the vacuum
procedure you have to hold on to the vacuum bell jar!)
- the lid of the container is closed properly
- the black rubber seal on the lid of the container is properly
attached to the lid
- the black rubber seal is porous or has holes
- the vacuum hose shows defects in the connection section or the end is broken off
- the security lock of the vacuum chamber is all the way to the left
and the vacuum chamber is properly assembled
- the container is overloaded - Leave 3 cm spare room underneath the lid!
• Folds, crumbs, grease or dampness on the sealing band section of the
bag can cause leaking. Open the bag, clean the inside of the plastic bag
in the section where you want to seal it and seal the bag again.
• Some food (such as fresh fruit and vegetables) can ferment or release
their natural gases.
• Lack of refrigeration or changing temperatures can cause food to spoil.
• Check if the plastic bag has a hole - You can identify this by dipping
the sealed plastic bag into water. If there is a hole, air would escape
when you put gentle pressure on the plastic bag. Depending on the position
of the hole either seal the plastic bag again or use a new one.
• Check if:
- the black rubber seal is porous or shows holes
- the sealing ring on the lid of the container is properly assembled,
dirty or damaged
Waste disposal
The appliance has to be disposed by the definition of the regional waste disposal of electricalscrap. If nec-
essary get information of the regional waste management enterprise.
Warranty
We guarantee that all our products are free of defects at the time of purchase. Any demonstrable man-
ufacturing or material defects will be to the exclusion of any further claim and within 2 years after pur-
chasing the appliance free of charge repaired or substituted. There is no Warranty claim of the purchaser
if the damage or defect of the appliance is caused by inappropriate treatment, over loading or installation mis-
takes. The Warranty claim expires if there is any technical interference of a third party without an writ-
ten agreement. The purchaser has to present the sales slip in assertion-of-claims and has to bear all
charges of costs and risk of the transport.
GASTROBACK GmbH
Gewerbestraße 29 • D-21279 Hollenstedt/Germany
http://www.gastroback.de • E-Mail: [email protected]
46011_DesignPlusVakuumierer_Manual.qxp 13.12.2006 10:30 Seite 30